Performance research on piezoelectric pumps based on holistic opening valve and cantilever valve

SUN Xiao-feng; YANG Zhi-qiang; LIU Xiao-lun; LI Xin-xin; LIN Jing-guo

doi:null

您当前的位置：

首页 >

文章列表页 >

Performance research on piezoelectric pumps based on holistic opening valve and cantilever valve

Article | 更新时间：2020-08-12

- Performance research on piezoelectric pumps based on holistic opening valve and cantilever valve
- Optics and Precision Engineering Vol. 14, Issue 4, Pages: 648-651(2006)
- 作者机构：
  
  1. 吉林大学机械工程与自动化学院,吉林长春 130025
  2. 吉林化工学院机械和电子工程系吉林,132022
  3. 东北师范大学,吉林长春,130022
- 作者简介：
- 基金信息：
- DOI：
  CLC： TH38;TN384
- Received：14 October 2005，
  
  Revised：18 August 2006，
  
  Published：2006
- 稿件说明：
移动端阅览
孙晓锋, 杨志强, 刘晓论, 李欣欣, 林敬国. 整体开启阀与悬臂梁阀压电泵性能研究[J]. 光学精密工程, 2006,14(4): 648-651

SUN Xiao-feng, YANG Zhi-qiang, LIU Xiao-lun, LI Xin-xin, LIN Jing-guo. Performance research on piezoelectric pumps based on holistic opening valve and cantilever valve[J]. Editorial Office of Optics and Precision Engineering, 2006,14(4): 648-651
孙晓锋, 杨志强, 刘晓论, 李欣欣, 林敬国. 整体开启阀与悬臂梁阀压电泵性能研究[J]. 光学精密工程, 2006,14(4): 648-651 DOI：

SUN Xiao-feng, YANG Zhi-qiang, LIU Xiao-lun, LI Xin-xin, LIN Jing-guo. Performance research on piezoelectric pumps based on holistic opening valve and cantilever valve[J]. Editorial Office of Optics and Precision Engineering, 2006,14(4): 648-651 DOI：

摘要

设计了两种形式的被动截止薄膜阀整体开启阀与悬臂梁阀

对两种形式阀的过流特性进行了理论分析

并应用两种形式的阀体制成了双腔串联压电泵的样机。对样机的实验测试表明

整体开启阀压电泵的自吸能力和输出流量都要好于悬臂梁阀压电泵。在200 V交流电压驱动下

前者的最大自吸高度和输出流量分别为430 mm水柱和972 ml/min

而后者为410 mm水柱和480 ml/min。

Abstract

The flow performance characteristics of two check valves

the holistic opening valve and the cantilever valve

were investigated. The prototype of piezoelectric pump with double series-wound chambers was manufactured in two form valves. The experimental results show that the self-suck ability and output flux of the piezoelectric pump with holistic opening valve are better than the piezoelectric pump with cantilever valve. With the alternating current of 200 V

the maximum self-suck height of the formers is 430 mm water column (the pressure is about 43 kPa)

and the maximum output flux is 972 ml/min

the counterpart value of the latter piezoelectric pump is 410 water column and 480 ml/min

respectively.

关键词

Keywords

references

GERLACH T, WURMUS H. Working principle and performance of the dynamic micropump [J]. Sensors and Actuators A, 1995,50:135-140.[2] 阚君武,杨志刚,程光明. 压电泵的现状与发展[J]. 光学精密工程,2002,10 (6):619-625. KAN J W,YANG ZH G,CHENG G M.Research on piezoelectric pump and its development[J]. Optics and Precision Engineering, 2002,10 (6):619-625.(in Chinese)[3] 白韶红. 微型阀和微型泵的原理与应用[J]. 传感器世界,2004,18 (3):29-32. BAI SH H.The principle and application for microvalve and micropump[J].Sensor World, 2004,18 (3):29-32.(in Chinese)[4] 李勇,周兆英,叶雄英. 微型阀和微型泵进展[J]. 仪器仪表学报,1996,17(1):56-60. LI Y,ZHOU ZH Y,YE X Y.An overview of research on microvalves and micropumps .Chinese Journal of Scientific Instrument, 1996,17(1):56-60.(in Chinese)[5] 尹执中,徐宁,庞江涛,等. 热驱动微型泵的实验研究 . 功能材料与器件学报,2000,6 (2):65-70. YIN ZH ZH,XU N,PANG J T,et al.Exprimental study on thermal actuated micropump[J].Journal of Materal and Devices,2000,6 (2):65-70.(in Chinese)[6] 尹执中,庞江涛,胡桅林,等. 悬臂梁式微型阀[J]. 仪表技术与传感器,2000,(3):38-43. YIN ZH ZH,PENG J T,HU W L, et al.Cantilever microvalve[J]. Instrument Technique and Sensor, 2000,(3):38-43.(in Chinese)[7] 阚君武,吴一辉,杨志刚,等. 悬臂梁微型阀特性研究 . 哈尔滨工业大学学报,2005,37(2):190-193. KAN J W,WU Y H,YANG ZH G, et al.Study on the performance of micro-cantilever valve[J].Journal of Harbin Institute of Technology, 2005,37(2):190-193.(in Chinese)[8] 程光明,刘国君,杨志刚,等. 基于悬臂梁阀的微型压电泵的实验研究[J]. 机械科学与技术,2005,24(10):1181-1183. CHENG G M,LIU G J,YANG ZH G, et al.Experimental research on piezoelectric micro-pump using cantilever check valve[J].Mechanical Science and Technology, 2005,24(10):1181-1183.(in Chinese)[9] 杨树臣,程光明,刘国君,等. 微型压电泵系统的设计研究[J]. 光学精密工程,2005,13(3):319-322. YANG SH CH,CHENG G M, LIU G J, et al.Design of piezoelectric micro-pump . Optics and Precision Engineering, 2005,13(3):319-322.(in Chinese)[10] 曾平,程光明,刘九龙,等. 双腔薄膜阀压电泵的试验研究[J]. 光学精密工程,2005,13(3):311-316. ZENG P,CHENG G M,LIU J L,et al. Experimental research on double-chambered piezoelectric pump with membrane valves[J].Optics and Precision Engineering, 2005,13(3):311-316.(in Chinese)

Views

270

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Principle and experimental verification of valve-less pump

Practical research on computer chip water cooling system with combined piezoelectric pump unit

Analysis on sucking process outflow phenomenon of piezoelectric pump

Research on vibration and pump flow rate of valveless piezoelectric pump with Y-shape tubes

Experimental research on double-chambered piezoelectric pump with membrane valves

Related Author

Jing JI

Li-qing ZHAO

Shu-yun WANG

Guang-ming CHENG

Zhong-hua ZHANG

Song CHEN

Xin-yi XIE

Yong-hua JIANG

Related Institution

College of Mechanical and Electrical Engineering, Qingdao Agricultural University

Institute of Precision Machinery and Instrument, Zhejiang Normal University

Mechanical Science and Engineering College,Jilin University

北京联合大学机电学院

北京工业大学机械工程及应用电子技术学院

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰