Development of vacuum application solar simulation Xe flash-lamp array

REN Jian-yue; SU Ke-qiang; WANG Bing; CHEN Chang-zheng; ZHANG Jun

doi:10.3788/OPE.20101808.1699

您当前的位置：

首页 >

文章列表页 >

Development of vacuum application solar simulation Xe flash-lamp array

Article | 更新时间：2020-08-12

- Development of vacuum application solar simulation Xe flash-lamp array
- Optics and Precision Engineering Vol. 18, Issue 8, Pages: 1699-1706(2010)
- 作者机构：
  
  1. 中国科学院长春光学精密机械与物理研究所,长春 130033
  2. 中国科学院研究生院,北京 100039
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20101808.1699
  CLC： V416.5;V524.2
- Received：27 June 2009，
  
  Revised：13 September 2009，
  
  Published Online：20 August 2010，
  
  Published：20 August 2010
- 稿件说明：
移动端阅览
任建岳, 苏克强, 王兵, 陈长征, 张军. 真空应用太阳模拟灯及其灯阵的研制[J]. 光学精密工程, 2010,18(8): 1699-1706

REN Jian-yue, SU Ke-qiang, WANG Bing, CHEN Chang-zheng, ZHANG Jun. Development of vacuum application solar simulation Xe flash-lamp array[J]. 光学精密工程, 2010,18(8): 1699-1706
任建岳, 苏克强, 王兵, 陈长征, 张军. 真空应用太阳模拟灯及其灯阵的研制[J]. 光学精密工程, 2010,18(8): 1699-1706 DOI： 10.3788/OPE.20101808.1699.

REN Jian-yue, SU Ke-qiang, WANG Bing, CHEN Chang-zheng, ZHANG Jun. Development of vacuum application solar simulation Xe flash-lamp array[J]. 光学精密工程, 2010,18(8): 1699-1706 DOI： 10.3788/OPE.20101808.1699.

摘要

为了对某相机进行热平衡试验

并克服传统太阳模拟器结构复杂、成本较高、光效利用率低的缺点

提出了将太阳模拟灯阵整体放在真空罐内使用的研制方案。首先

对该方案所需解决的各种问题进行了理论分析

计算得出模拟灯阵的辐照度要求为635.2~905.4 W/m

光学系统效率为0.144 4。分析了真空罐液氮冷却系统的导热能力

结果显示

该冷却系统温度升高

为2.0741 K

小于其过冷度4 K

表明该冷却系统可以将太阳模拟灯阵灯的热量导出。对系统热设计进行了分析和讨论

结果表明

积分器和反射镜的温度在200 ℃左右

氙灯灯极温度在92 ℃左右

满足其长时间正常工作的条件。最后

测试了模拟灯阵的技术参数

结果显示其照度为490.37~1 000.56 W/m

连续可调

辐照不均匀度

5％

辐照不稳定度

5％/h

各项指标均满足设计指标要求。

Abstract

In order to do the thermal balance tests for some type space-cameras and to overcome the shortcomings of traditional solar simulators in complicated structure

high costs and low light efficiencies

a simulated solar Xe flash-lamp array placed in a vacuum tank was developed. The theoretical principles of the simulated solar lamp array were analyzed

then it pointed out that its irradiance should be set to 635.2~905.4 W/m

and its efficiency of optical system is 0.144 4. The heat conduction ability of the liquid nitrogen cooling system in the vacuum tank was analyzed

and the results indicate that the temperature of cooling system in the vacuum tank

is 2.074 1 K and lower than a super cooling temperature of 4 K

which means that the liquid nitrogen cooling system can export the heat of solar simulated lamp array out from the vacuum tank. The thermal design of the simulated lamp was analyzed and discussed

results show that the temperatures of optical integrator and mirror are all around 200 ℃

and the temperatures of cathode and negative electrodes of the lamp are around 92 ℃

which meets their normal working conditions for a long time. Finally

the technological specifications of the simulated solar lamp were tested

it is shown that its radiation intensities are 600~1 000 W/m

and the inuniformity and unsteadiness of radiation are less than 5％ and 5％/h

respectively. Those data are well coincident with the design targets

关键词

Keywords

references

刘洪波. 太阳模拟技术[J]. 光学精密工程,2001,9(2):177-181.

LIU H B. Solar simulation technology[J].Opt.and Precision Eng.,2001,9(2):177-181.(in Chinese)

王俊,黄本城,万才大,等.环境模拟技术[M]. 北京:国防工业出版社,1996.

WANG J,HUANG B CH,WAN C D,et al..Environment simulation technology[M].Bering:National Defense Industry Press,1996.(in Chinese)

EDDY R. Design and construction of JPL SSL5B solar simulator .JPL internal document,1968-01.

NAUKAMURA Y, TOMITA T, et al..13-m diameter space simulation test facility .ESA SP-304,1990-09:107-112.

庞贺伟,黄本诚,臧友竹,等. KM6太阳模拟器设计概述[J]. 航天器环境工程,2006,23(3):125-133.

PANG H W,HUANG B CH,ZANG Y ZH,et al.. Design of KM6 Solar Simulator[J]. Spacecraft Environment Engineering, 2006,23(3):125-133.(in Chinese)

柯受全.卫星环境工程和模拟试验[M]. 北京:中国宇航出版社,1998.

KE SH Q.Satellite environment engineering and simulation experiment[M].Beijing:China Astronautic Publishing House,1998.(in Chinese)

杨林华,李竑松. 国外大型太阳模拟器研制技术概述[J]. 航天器环境工程,2009,26(2):162-167.

YANG L H,LI H S. The development of large solar simulators in the world [J].Spacecraft Environment Engineering,2009,26(2):162-167. (in Chinese)

张林华,王元. 全光谱太阳模拟器光源选择的实验研究[J]. 山东建筑大学学报,2007,22(6):531-536.

ZHANG L H, WANG Y. Experimental study on the selection of light sources for full spectrum solar simulators[J]. Journal of Shandong Jian zhu university,2007,22(6):531-536.(in Chinese)

ASTME891-87, Standard table for terrestrial direct normal solar spectral irradiance for air mass 1.5[S].

ASTME892-87, Standard table for terrestrial solar spectral irradiance air mass 1.5 for a 37tiled surface[S].

庞贺伟,黄本诚,臧友竹,等. KM6太阳模拟器设计概述[J]. 航天器环境工程,2006,23(3):125-133.

PANG H W,HUANG B CH,ZANG Y ZH,et al.. Design of KM6 Solar Simulator[J]. Spacecraft Environment Engineering, 2006,23(3):125-133.(in Chinese)

柯受全.卫星环境工程和模拟试验[M]. 北京:中国宇航出版社,1998.

KE SH Q.Satellite environment engineering and simulation experiment[M].Beijing:China Astronautic Publishing House,1998.(in Chinese)

中华人民共和国国家标准GB／T12637-1990. 太阳模拟器通用规范[S]. 北京:中国标准出版社,1990.

National Standard of the Peoples Republic of China GB／T12637-1990. General specification for solar simulator[S]. Beijing: Standards Press of China, 1990. (in Chinese)

仲跻功. 太阳模拟器光学系统的几个问题[J]. 太阳能学报,1983,4(2):187-193.

ZHONG J G.On some questions in optical system of the solar simulator[J].Acta Energiae Solaris Sinica,1983,4(2):187193.(in Chinese)

王元,张林华. 一种新型全光谱太阳模拟器设计[J]. 太阳能学报,2006,27(11):1132-1136.

WANG Y,ZHANG L H.Design of a new type of fullspectrum solar simulator[J].Acta Energiae Solaris Sinica,2006,27(11):1132-1136.(in Chinese)

Views

477

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Design of 50000 fps camera system for shooting of high-speed collision process

Thermal design and verification of micro remote-sensing satellite in low inclination orbit

Thermal design and validation of multispectral max width optical remote sensing satellite

Review on thermal design of machine tool spindles

Solar simulator based on LED array light source

Related Author

YAN A-qi

WANG Hao

PENG Jian-wei

YANG Hong-tao

SHI Kui

Tian BAI

Lin KONG

Jian HUANG

Related Institution

University of Chinese Academy of Sciences

Xi′an Institute of Optics and Precision Mechanics，Chinese Academy of Sciences， Xi′an

Chang Guang Satellite Technology LTD.

Chang Guang Satellite Technology Limited Company

Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Sciences

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰