Fabrication of large grain size p-Si film by phase modulated excimer laser crystallization

ZHANG Jian; LIN Guang-ping; ZHANG Rui; CUI Guo-yu; LI Chuan-nan

doi:10.3788/OPE.20122001.0058

您当前的位置：

首页 >

文章列表页 >

Fabrication of large grain size p-Si film by phase modulated excimer laser crystallization

Article | 更新时间：2020-08-12

- Fabrication of large grain size p-Si film by phase modulated excimer laser crystallization
- Optics and Precision Engineering Vol. 20, Issue 1, Pages: 58-63(2012)
- 作者机构：
  
  吉林大学电子科学与工程学院集成光电子学国家重点联合实验室吉林大学实验区,吉林长春,130012
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20122001.0058
  CLC： TN305.7;TN304.055
- Received：17 June 2011，
  
  Revised：29 July 2011，
  
  Published Online：25 January 2012，
  
  Published：25 January 2012
- 稿件说明：
移动端阅览
张健, 林广平, 张睿, 崔国宇, 李传南. 准分子激光相位掩模法制备大晶粒尺寸多晶硅薄膜[J]. 光学精密工程, 2012,20(1): 58-63

ZHANG Jian, LIN Guang-ping, ZHANG Rui, CUI Guo-yu, LI Chuan-nan. Fabrication of large grain size p-Si film by phase modulated excimer laser crystallization[J]. Editorial Office of Optics and Precision Engineering, 2012,20(1): 58-63
张健, 林广平, 张睿, 崔国宇, 李传南. 准分子激光相位掩模法制备大晶粒尺寸多晶硅薄膜[J]. 光学精密工程, 2012,20(1): 58-63 DOI： 10.3788/OPE.20122001.0058.

ZHANG Jian, LIN Guang-ping, ZHANG Rui, CUI Guo-yu, LI Chuan-nan. Fabrication of large grain size p-Si film by phase modulated excimer laser crystallization[J]. Editorial Office of Optics and Precision Engineering, 2012,20(1): 58-63 DOI： 10.3788/OPE.20122001.0058.

摘要

为扩大晶粒尺寸并降低晶粒间界缺陷对多晶硅薄膜晶体管的不良影响

采用准分子激光相位掩模法制备了大晶粒尺寸的多晶硅薄膜。首先

在无相位掩模时利用不同能量密度的准分子激光晶化非晶硅薄膜

通过扫描电镜观测晶粒尺寸确定超级横向生长的能量窗口;然后

在该能量密度下采用周期为1 073 nm的相位掩模板对入射光束进行相位调制

在样品表面形成人工可控的横向温度梯度

使非晶硅熔化并横向生长结晶为多晶硅;最后

对薄膜特性进行测量

并与非晶硅薄膜和超级横向生长制备的多晶硅薄膜进行比较。结果表明:本文方法制作的薄膜的平均晶粒尺寸提高了一个数量级

达到了228.24 nm;薄膜电阻率降低一个数量级

为18.9 m;且晶粒分布规则有序。该方法能有效提高多晶硅薄膜的电学特性

适用于高质量多晶硅薄膜器件的制作。

Abstract

To enlarge the grain size and decrease the effect of the defect between the grain boundaries on a p-Si film transistor

a phase modulated excimer laser crystallization technique is used to fabricate the uniform p-Si film with a large grain size. First

an energy window for super lateral growth is determined by measuring the grain size of p-Si film fabricated with different laser energy intensities. Then

the spatial distribution of the input laser is modulated by a phase mask with a period of 1 073 nm and an artificially controlled lateral temperature gradient is induced on the a-Si film

which leads the a-Si to be melten and crystallized into p-Si grains by super lateral growth. Finally

the characteristics of the prepared p-Si film are measured and compared with those of the a-Si film and the p-Si film fabricated by super lateral growth technique. The results show that the grain size of the p-Si film is 228.24 nm

which is ten times of that fabricated by super lateral growth under the same processing parameters; the electrical resistivity of the prepared sample is 18.9 m

which is lower by an order magnitude than that prepared by super lateral growth. Furthermore

the distribution of the grain is more uniform than that fabricated by other techniques. The reported technique can increase the electrical characteristics of the p-Si film greatly and is suitable for the fabrication of high quality p-Si devices.

关键词

Keywords

references

KUO C C. In situ time-resolved optical measurements of a-Si thin films during excimer laser crystallization[J].Optik, 2011,122(8):655-659.[2] KUO C C. Phase transformation mechanism in pulsed excimer laser crystallization of amorphous silicon thin films[J]. Lasers in Engineering, 2010, 19 (3-4): 225-238.[3] 刘松林. 多晶硅薄膜ELC制备方法中控制纵向热流的探索[J] .科技创新导报,2010,32:11-13. LIU S L. Investigation in controlling longitudinal heat flow during the fabrication of poly-silicon thin film by ELC technique[J]. Science and Technology Innovation Herald,2010,32:11-13.(in Chinese)[4] 尹亮,陈伟平,刘晓为,等. 闭环加速度计CMOS 接口电路 [J].光学精密工程,2009,17(6):1311-1315. YIN L, CHEN W P,LIU X W, et al.. CMOS interface circuit for closed loop accelerometer[J]. Opt. Precision Eng., 2009, 17 (6):1311-1315.(in Chinese)[5] 周春兰,王文静,李海玲,等. 用电学参数表征晶体硅太阳电池特性 [J].光学精密工程,2008,16(7):1163-1170. ZHOU CH L,WANG W J,LI H L, et al.. Characterization of crystalline silicon solar cells by electrical parameters[J]. Opt. Precision Eng., 2008,16(7):1163-1170.(in Chinese)[6] 赵学庆, 刘晶儒 , 易爱平,等. 平滑化窄脉冲高功率准分子激光放大技术 [J].光学精密工程,2011,19(2): 397-406. ZHAO X Q, LIU J R, YI A P , et al.. Amplification of high power short pulse excimer laser with beam smoothing[J].Opt. Precision Eng., 2011, 19(2):397-406.(in Chinese)[7] 薛全喜, 赵学庆, 华恒祺,等. 高功率XeCl准分子激光系统前端平滑实验 [J].光学精密工程,2011, 19(2):332-339. XUE Q X , ZHAO X Q , HUA H Q ,et al.. Seed beam smoothing for high power XeCl excimer laser system[J]. Opt. Precision Eng., 2011, 19(2):332-339.(in Chinese)[8] KAKKAD R, CHOI B D. Enhancement of solid-phase crystallization kinetics of amorphous silicon by annealing in a high-pressure H2O ambient[J]. Journal of the Korean Physical Society, 2009, 55(1):1-4.[9] JIN B J, Oh S J, KIM D H, et al.. Activation behavior of SLS and ELC poly-Si after ion shower doping . IDW '06: Proceedings of the 13th International Display Workshops, 2006 ,1-3: 769-772.[10] LIAO Y P , SHAO X B, GAO F L, et al.. Nickel-disilicide-assisted excimer laser crystallization of amorphous silicon[J]. Chinese Physics, 2006,15(6):1310-1314.[11] CHIKOGA S U, IBARAKI N. Low temperature poly-Si TFT-LCD by excimer laser anneal[J].Thin Solid Films,2001,383:19-24.[12] SAMESHIMA T, KOHNO A, SEKIYA M, et al.. SiO2 formation by thermal evaporation of SiO in oxygen atmosphere used to fabrication of high performance polycrystalline silicon thin film transistors[J].Appl.Phys.Lett,1994,64:1018.[13] KUO Y, KOZLOWSKI P M. Polycrystalline silicon formation by pulsed rapid thermal annealing of amorphous silicon[J]. Appl. Phys. Lett. 1996,69:1092.[14] LEE S J, LEE S W, LEE K E, et al.. Electrical characterization of polycrystalline silicon thin film transistors crystallized by a new alignment sequential lateral solidification process[J].Phys.Scr.,2011,83:055802.[15] SASAKI N, KITANARA K, YAMAMOTO K. Cha racterization of electrochemically-active defects in Si-film laser-crystallized with directional SLS by measuring the stress release during secco etching .Sid International Symposium Digest of Technical Papers., 2009,40(13): 632-635.[16] IM J S, KIM H J. On the super lateral growth phenomenon observed in excimer laser-induced crystallization of thin Si films[J].Appl.Phys.Lett.,1994,64:2303.[17] SPOSILIM R S, IM J S. Sequential lateral solidification of thin silicon films on SiO2[J]. J Appl.Phys, 1996,69(19):2864-2866.[18] 张健,郑杰,张玉书. 菲波纳契准周期超结构光纤光栅 [J].光子学报,2009,38(8):2050-2054. ZHANG J, ZHENG J,ZHANG Y SH. Fibonacci Quasi-periodic superstructure fiber bragg gratings[J]. Acta Photonica Sinica, 2009,38 (8):2050-2054.(in Chinese)

Views

601

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Phase mask for fabrication of fiber Bragg gratings by femtosecond laser

Automatic alignment of multiplexed beams of excimer laser system based on fluorescence imaging

Suppression of ASE from excimer laser using cascaded UV electro-optical switch

Automatic alignment of double paths in electron pumped excimer laser amplifier

Seed beam smoothing for high power XeCl excimer laser system

Related Author

Shuang-shuang HUANG

Jin-chao LU

Xin-hua CHEN

Jian-hong WU

Quan LIU

ZHAO Jun

YI Ai-ping

FENG Gang

Related Institution

School of Optoelectronic Science and Engineering & Collaborative Innovation Center of Suzhou Nano Science and Technology, Soochow University

Key Lab of Advanced Optical Manufacturing Technologies of Jiangsu Province & Key Lab of Modern Optical Technologies of Education Ministry of China, Soochow University

State Key Laboratory of Laser Interaction with Matter, Northwest Institute of Nuclear Technology

State Key Laboratory of Laser Interaction with Matter, Northwest Institute of Nuclear Technology, Xi'an 710024, China

State Key Laboratory of Laser Interaction with Matter, Northwest Institute of Nuclear Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰