Design of ultra-high resolution CCD imaging systems

XU Wen-hai; WU Hou-de

doi:10.3788/OPE.20122007.1603

您当前的位置：

首页 >

文章列表页 >

Design of ultra-high resolution CCD imaging systems

更新时间：2020-08-12

- Design of ultra-high resolution CCD imaging systems
- Optics and Precision Engineering Vol. 20, Issue 7, Pages: 1603-1610(2012)
- 作者机构：
  
  大连海事大学信息科学技术学院,辽宁大连,中国,116026
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20122007.1603
  CLC： P754.4;TN386.5
- Received：23 March 2012，
  
  Revised：10 April 2012，
  
  Published Online：10 July 2012，
  
  Published：10 July 2012
- 稿件说明：
移动端阅览
许文海, 吴厚德. 超高分辨率CCD成像系统的设计[J]. 光学精密工程, 2012,20(7): 1603-1610

XU Wen-hai, WU Hou-de. Design of ultra-high resolution CCD imaging systems[J]. Editorial Office of Optics and Precision Engineering, 2012,20(7): 1603-1610
许文海, 吴厚德. 超高分辨率CCD成像系统的设计[J]. 光学精密工程, 2012,20(7): 1603-1610 DOI： 10.3788/OPE.20122007.1603.

XU Wen-hai, WU Hou-de. Design of ultra-high resolution CCD imaging systems[J]. Editorial Office of Optics and Precision Engineering, 2012,20(7): 1603-1610 DOI： 10.3788/OPE.20122007.1603.

摘要

介绍了基于50 Mpixel超高分辨率全帧型CCD芯片KAF50100的成像系统设计方法。该系统采用幕帘式焦平面机械快门对CCD进行曝光控制

CCD输出图像信号在专用模拟前端(AFE)芯片AD9845B中进行处理和模数(A/D)转换后

经现场可编程门阵列(FPGA)缓存和排序

通过低压差分信号(LVDS)接口发送至上位机。系统中所有驱动时序和控制信号均由FPGA产生

上位机通过RS422总线对系统进行命令控制。针对KAF50100四路输出不均匀性问题提出了基于最小二乘法拟合的校正方法。实验验证表明

系统可在KAF50100的最大速度模式下工作

像素读出速度为4×18 MHz

最大帧速为1 frame/s

电路读出随机噪声为2.76@12bit

动态范围为63.4db。该成像系统设计方法可以充分发挥KAF50100的性能

并且具有良好的通用性和扩展性

可以广泛应用于超高分辨率CCD成像系统的设计中

如可见光水下探测、卫星遥感、天文观测等。

Abstract

A design method for ultra high resolution image systems based on full frame CCD KAF50100 was proposed

in which a mechanical rolling shutter was adopted to control the exposure. The Analog Front End (AFE) chip AD9845B was used to process and digitize the analog output of KAF50100 and the digital image signal from the AFE was buffered and arranged in a block ram of Field Programming Gate Arry(FPGA)

then was sent out through a Low Voltage Differential Signaling(LVDS) interface. All the control signals and drive timing signals were generated by the FPGA and the RS422 interface was used to receive command and upload the status of system. The least square method was adopted to correct the non-uniformity from four analog outputs of the CCD sensor. Experiment shows that the CCD sensor KAF50100 can work at a top output speed

its pixel output rate is 4?18 MHz

and the maximum frame rate

output noise and the dynamic range are 1 frame/s

2.76@12bit and 63.4 dB

respectively. With better flexibility and extendibility

this design method can be widely used in ultra high resolution imaging fields like visible light underwater detection

satellite remote sensing and astronomical observation.

关键词

Keywords

references

金伟其,王霞,曹峰梅,等. 水下光电成像技术与装备研究进展(下) [J].红外技术,2011,33(3):125-132. JIN W Q, WANG X, CAO F M, et al.. Review of underwater opto-electrical imaging technology and equipment(Ⅱ) [J]. Infrared Technology, 2011, 33(3): 125-132. (in Chinese)

阮锐. CCD技术在海洋测绘领域中的应用 [J].海洋测绘,2011,31(3):80-82. RUAN R. Application of CCD technology in the field of hydrographic surveying and charting [J]. Hydrographic Surveying and Charting, 2011, 31(3): 80-82. (in Chinese)

马庆军,宋克非,曲艺,等. 紫外临边成像光谱仪CCD电路系统的设计 [J].光学精密工程,2011,19(7):1538-1545. MA Q J, SONG K F, QU Y, et al.. Design of CCD circuit systems for ultraviolet limb imaging spectrometers [J]. Opt. Precision Eng., 2011, 19(7):1538-1545. (in Chinese)

孙泽林,王昭,李明. 火炮稳定精度图像测试系统 [J].光学精密工程,2012,20(1):157-164. SUN Z L, WANG Z, LI M. Image test system for gun stabilization accuracy [J]. Opt. Precision Eng., 2012, 20(1): 157-164. (in Chinese)

刘光林,杨世洪,吴钦章,等. 高分辨率全帧CCD相机电路系统的设计 [J].中国科学院研究生院学报,2007,24(3):320-324. LIU G L, YANG S H, WU Q ZH, et al.. Design of high resolution camera system based on full frame CCDs [J]. Journal of the Graduate School of the Chinese Academy of Sciences, 2007, 24(3): 320-324. (in Chinese)

盛翠霞,张涛,纪晶,等. 高分辨率CCD芯片FTF4052M的驱动系统设计 [J].光学精密工程,2007,15(4):564-569. SHENG C X, ZHANG T, JI J, et al.. Design of CCD FTF4052M driver system with high sensitivity [J]. Opt. Precision Eng., 2007, 15(4): 564-569.(in Chinese)

BEN-EZRA, MOSHE. High resolution large format tile-scan camera: Design, calibration, and extended depth of field . 2010 IEEE International Conference on Computational Photography, ICCP 2010: 5585095.

BEN-EZRA, MOSHE. A digital gigapixel large-format tile-scan camera [J]. IEEE Computer Graphics and Applications, 2011, 31(1): 49-61.

曲国志,刘海英. CCD航空相机用长寿命帘幕式快门 [J].电光与控制,2011,18(11):77-79. QU G ZH, LIU H Y. A long life curtain-type shutter for aerial CCD cameras [J]. Electronics Optics & Control, 2011, 18(11): 77-79. (in Chinese)

杨少华,郭明安,李斌康,等. 百万像素电子倍增CCD数字化相机的设计 [J].光学精密工程,2011,19(21):2970-2976. YANG SH H, GUO M A, LI B K, et al.. Design of digital EMCCD camera with mega pixels [J]. Opt. Precision Eng., 2011, 19(21): 2970-2976. (in Chinese)

佟首峰,阮锦,郝志航. CCD图像传感器降噪技术的研究 [J].光学精密工程,2000,8(2):140-145. TONG SH F, RUAN J, HAO ZH H. Noise reducing scheme on output signal of CCD [J]. Opt. Precision Eng., 2000, 8(2): 140-145. (in Chinese)

程万胜,赵杰,蔡鹤皋. CCD像素响应非均匀的校正方法 [J].光学精密工程, 2008,16(2):314-318. CHENG W S, ZHAO J, CAI H G. Correction method for pixel response nonuniformity of CCD [J]. Opt. Precision Eng., 2008, 16(2): 314-318. (in Chinese)

米本和也.CCD/CMOS图像传感器基础与应用[M]. 北京:科学出版社 ,2006. KAZUYA Y. CCD/CMOS Image Sensor no Kiso to Ouyou [M]. Beijing: Science Press, 2006. (in Chinese)

Views

345

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Adaptive focusing evaluation algorithm for optical imaging of wafer positioning marks

Large field optical imaging system based on freeform surface optics

Position misalignment correction method for macroscopic Fourier ptychography based on particle swarm optimization

Research progress of normal-incidence optical system at extreme ultraviolet （EUV） wavelength

Rotary polarization detection imaging system based on dynamic vision sensor

Related Author

YANG Jin

ZHANG Hangying

MENG Kai

LOU Peihuang

XIONG Yupeng

CHEN Shiyu

HUANG Cheng

LU Wenwen

Related Institution

Key Laboratory of Aerospace Integrated Circuits and Microsystem， Ministry of Industry and Information Technology

National Key Laboratory of Microwave Photonics

College of Mechanical and Electrical Engineering， Nanjing University of Aeronautics and Astronautics

Laboratory of Science and Technology on Integrated Logistics Support， College of Intelligence Science and Technology， National University of Defense Technology

Nanhu Laser Laboratory， National University of Defense Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰