High precision Pt-resistance temperature measurement system

HU Peng-cheng; SHI Wei-ze; MEI Jian-ting

doi:10.3788/OPE.20142204.0988

您当前的位置：

首页 >

文章列表页 >

High precision Pt-resistance temperature measurement system

Micro/Nano Technology and Fine Mechanics | 更新时间：2020-08-13

- High precision Pt-resistance temperature measurement system
- Optics and Precision Engineering Vol. 22, Issue 4, Pages: 988-995(2014)
- 作者机构：
  
  哈尔滨工业大学超精密光电仪器工程研究所,黑龙江哈尔滨,150080
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20142204.0988
  CLC： TH811.1
- Received：05 December 2013，
  
  Revised：20 January 2014，
  
  Published：25 April 2014
- 稿件说明：
移动端阅览
胡鹏程, 时玮泽, 梅健挺. 高精度铂电阻测温系统[J]. 光学精密工程, 2014,22(4): 988-995

HU Peng-cheng, SHI Wei-ze, MEI Jian-ting. High precision Pt-resistance temperature measurement system[J]. Editorial Office of Optics and Precision Engineering, 2014,22(4): 988-995
胡鹏程, 时玮泽, 梅健挺. 高精度铂电阻测温系统[J]. 光学精密工程, 2014,22(4): 988-995 DOI： 10.3788/OPE.20142204.0988.

HU Peng-cheng, SHI Wei-ze, MEI Jian-ting. High precision Pt-resistance temperature measurement system[J]. Editorial Office of Optics and Precision Engineering, 2014,22(4): 988-995 DOI： 10.3788/OPE.20142204.0988.

摘要

普通四线制铂电阻测温系统受恒流源长短期漂移、导线热电动势影响，其测量准确度难以超过0.1℃量级。本文分析了一种改进型4线制高精度铂电阻测温方法的原理误差，并设计了相应的高精度铂电阻测温系统。采用温度系数小、阻值稳定性好的参考电阻作为铂电阻阻值测量基准，消除了恒流源长期漂移引起的铂电阻测温误差；分别在正、反向恒流激励条件下测量了铂电阻上的电压，利用导线热电势大小与方向的短期不变性，对得到的两电压量求差以消除导线热电势的影响；通过半导体致冷器（TEC）控制恒流源温度来减小恒流源的短期电流漂移，进而减小其对铂电阻测温精度的影响；设计了精度高、阶跃响应速度快的分时复用式电压信号采集单元用来高精度地测量铂电阻和参考电阻上电压量的比值。等效实验和校准实验结果表明，高精度铂电阻测温系统的测量稳定性优于0.005 ℃/10 day，测量分辨力优于0.005 ℃，测量准确度为0.02 ℃（

=2），满足超精密激光干涉测量系统提出的高精度温度测量需求。

Abstract

Interfered by factors such as short and long term drifts of a constant current source and the thermal electromotive force of a wire

the measurement accuracy of conventional 4-wire Pt-resistance temperature measurement system is hard to achieve the order of 0.1℃. After analyzing the principle error of an enhanced 4-wire Pt-resistance temperature measurement method

a high precision Pt-resistance temperature measurement system was designed. By using a reference resistance with small temperature coefficient and high stability as the Pt-resistance measurement datum

the temperature measurement error caused by the long term drift of a constant current source was eliminated. At the same time

the short-term drift of the constant current source was suppressed by temperature control using a Thermoelectric Cooler(TEC). For wire thermal electromotive force

it was a great advantage to be short-term invariable. Measured under the positive and negative current conditions

the two voltages on Pt-resistance were subtracted. In this way

the effect of wire thermal electromotive force was eliminated. To realize high precision voltage measurement for Pt-resistance and reference resistance

a time-sharing voltage acquisition unit with high precision and quick step response was also designed. Experimental results show that the high precision Pt-resistance temperature measurement system can achieve the stability of 0.005 ℃/10 day

the resolution of 0.005 ℃ and the accuracy of 0.02 ℃(

=2). It meets the requirements of high accuracy temperature measurement in ultra-precision laser interferometers.

关键词

Keywords

references

FEIGE V K S, BALK L J. Calibration of a scanning probe microscope by the use of an interference-holographic position measurement system[J]. Meas. Sci. Tech., 2003, 14:1032-1039.

贾方秀, 丁振良. 激光测距仪的脉冲电流供电温度控制系统[J]. 光学精密工程, 2009, 17(9):2128-2135. JIA F X, DING ZH L. Temperature control system supplied by pulse-drive current for laser range finder[J]. Opt. Precision Eng., 2009, 17(9):2128-2135.(in Chinese)

胡鹏程, 谭久彬, 闫磊, 等. 一种基于温度轨迹控制的塞曼稳频激光器预热方法[J]. 光学精密工程, 2008, 16(6):91-95. HU P CH, TAN J B, YAN L, et al..Preheating method for frequency stabilized Zeeman He-Ne laser based on temperature trajectory control[J]. Opt. Precision Eng., 2008, 16(6):91-95.(in Chinese)

张福民, 曲兴华, 叶声华. 面向对象的大尺寸测量不确定度分析[J]. 光学精密工程, 2008, 16(11):2239-2243. ZHANG F M, QU X H, YE SH H. Uncertainty estimation of large2scale measurement for special fitting task[J]. Opt. Precision Eng., 2008, 16(11):2239-2243.(in Chinese)

HIETA T, MERIMAA M, VAINIO M, et al. High-precision diode-laser-based temperature measurement for air refractive index compensation[J]. Appl. Opt., 2011, 50(31):5990-5998.

DOROZHOVETS N V, HAUSOTTE T, MANSKE E, et al. Novel control scheme for a high-speed metrological scanning probe microscope[J]. Meas. Sci. Technol., 2011, 22: 094012.

胡鸿志. 基于新型温度传感器的数字温度计设计[J]. 电子测量与仪器学报. 2011, 25(8):741-744. HU H Z. Design of digital thermometer based on novel temperature sensor[J].Thermal-resistor temperature measuring device based on current method[J]. Journal of Electronic Measurement and Instrument. 2011, 25(8):741-744.(in Chinese)

金伟正. 实用四线制PT100测温电路研究[J]. 电子测量技术, 2000, 2:27-28. JIN W ZH. The new kind of 4-wire temperature measure circuit using Pt100[J]. Electronic Measurement Technology, 2000, 2:27-28. (in Chinese)

张培. 精密温度测量系统研究[D]. 哈尔滨:哈尔滨工业大学, 2009. ZHANG P. Research on precise temperature measurement system [D]. Harbin: Harbin Institute of Technology, 2009.(in Chinese)

张瑜, 张升伟. 基于铂电阻传感器的高精度温度检测系统设计[J]. 传感技术学报, 2010, 23(3):311-314. ZHANG Y, ZHANG SH W. A design of high accurate temperature measuring system based on platinum resistance transducers[J]. Chinese Journal of Sensors and Actuators, 2010, 23(3):311-314. (in Chinese)

Views

665

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰