Theory and experimental modal analysis of dual-mass vibrating silicon micro-gyroscope

JIANG Shao-dong; SU Yan; SHI Qin; QIU An-ping

doi:10.3788/OPE.20152302.0467

您当前的位置：

首页 >

文章列表页 >

Theory and experimental modal analysis of dual-mass vibrating silicon micro-gyroscope

更新时间：2020-08-13

- Theory and experimental modal analysis of dual-mass vibrating silicon micro-gyroscope
- Optics and Precision Engineering Vol. 23, Issue 2, Pages: 467-476(2015)
- 作者机构：
  
  南京理工大学机械工程学院,江苏南京,中国,210094
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20152302.0467
  CLC： V666.123;TP273
- Received：20 May 2014，
  
  Revised：27 June 2014，
  
  Published：25 February 2015
- 稿件说明：
移动端阅览
姜劭栋, 苏岩, 施芹等. 双质量振动式硅微陀螺理论和实验模态分析[J]. 光学精密工程, 2015,23(2): 467-476

JIANG Shao-dong, SU Yan, SHI Qin etc. Theory and experimental modal analysis of dual-mass vibrating silicon micro-gyroscope[J]. Editorial Office of Optics and Precision Engineering, 2015,23(2): 467-476
姜劭栋, 苏岩, 施芹等. 双质量振动式硅微陀螺理论和实验模态分析[J]. 光学精密工程, 2015,23(2): 467-476 DOI： 10.3788/OPE.20152302.0467.

JIANG Shao-dong, SU Yan, SHI Qin etc. Theory and experimental modal analysis of dual-mass vibrating silicon micro-gyroscope[J]. Editorial Office of Optics and Precision Engineering, 2015,23(2): 467-476 DOI： 10.3788/OPE.20152302.0467.

摘要

考虑硅微陀螺的设计和结构优化

研究了陀螺固有频率及模态对其性能的影响。针对本课题组研制的双质量振动式硅微陀螺

利用能量法建立了固有频率的理论公式

对硅微陀螺的低阶模态进行了理论分析

并利用有限元仿真和实验对理论分析结果进行了验证。结果显示:理论分析结果与仿真结果的最大误差为8.6%

与实验结果的最大误差为10.6%。利用Allan方差分析法对陀螺进行了静态性能实验

结果显示其角度随机游走为0.0578(°)/hr

1/2

零偏不稳定性为0.459(°)/hr。与传统的单纯依靠有限元仿真的模态定阶相比

本文建立的理论模型可以省略繁琐的结构参数调整过程

更高效地完成陀螺模态定阶

而且可用于陀螺的结构优化过程。

Abstract

For designing silicon micro-gyroscopes and optimizing their structures

the effects of intrinsic frequency and modal of a silicon micro-gyroscope on its performance were researched. On the basis of energy theorem

a theoretical formula of the intrinsic frequency was established

and the lowest frequency mode of the dual-mass vibrating silicon micro-gyroscope was analyzed. Then the analytical results were validated by the Finite Element Method (FEM) simulation and the experiment. Analysis results show that the largest analytical errors with respect to simulation and experiment are 8.6% and 10.6%

respectively. Moreover

the Allan Variance analysis was used to conduct a static performance experiment

and the results demonstrate that the Angle Random Walk (ARW) is 0.057 8(°)/hr

1/2

and the measured bias instability is 0.459(°)/hr. As compared with the traditional modal ordering method depending on the FEM

the proposed theoretical model avoids complex structure parameter adjustment processing

complements modal ordering of the silicon micro-gyroscope and can be used in the structure optimization of the silicon micro-gyroscope.

关键词

Keywords

references

施芹,苏岩,裘安萍,等. MEMS陀螺仪器件级真空封装技术[J]. 光学精密工程, 2009, 17(8): 1987-1992.

SHI Q, SU Y, QIU A P, et al.. Device level vacuum packaging technologies of MEMS gyroscopes [J]. Opt. Precision Eng., 2009, 17(8): 1987-1992. (in Chinese)

李建利,房建成,盛蔚,等. 双质量块调谐输出式硅MEMS陀螺仪的理论计算及仿真[J]. 光学精密工程, 2008, 16(3): 484-491.

LI J L, FANG J CH, SHENG W, et al.. Calculation and simulation of silicon MEMS gyroscope with dual-mass resonant output [J]. Opt. Precision Eng., 2008, 16(3):484-491. (in Chinese)

姜劭栋,裘安萍,施芹,等. 硅微陀螺仪正交耦合系数的计算及验证[J]. 光学精密工程, 2013, 21(1): 87-93.

JIANG SH D, QIU A P, SHI Q, et al.. Calculation and verification of quadrature coupling coefficient of silicon microgyroscope [J]. Opt. Precision Eng., 2013, 21(1): 87-93. (in Chinese)

BERNSTEIN J, CHO S, KING A T, et al.. A micromachined comb-drive tuning fork rate gyroscope[C]. Micro Electro Mechanical Systems, MEMS, 1993,93:143-148.

TRUSOV A A, SCHOFIELD A R, SHKEL A M. Micromachined rate gyroscope architecture with ultra-high quality factor and improved mode ordering[J]. Sensors and Actuators A: Physical, 2011, 165(1): 26-34.

WEINBERG M S, KOUREPENIS A. Error sources in in-plane silicon tuning-fork MEMS gyroscopes [J]. Microelectromechanical Systems,2006, 15(3): 479-491.

APOSTOLYUK V. Theory and Design of Micromechanical Vibratory Gyroscopes[M]. VS:Springer, 2006: 173-195.

WHITE R D. Effects of impact and vibration on the performance of a micromachined tuning fork gyroscope[D]. Massachusetts Institute of Technology, Dept. of Mechanical Engineering, 1999.

YOON S W, LEE S, NAJAFI K. Vibration-induced errors in MEMS tuning fork gyroscopes[J]. Sensors and Actuators A: Physical, 2012, 180: 32-44.

FEDDER G K. Simulation of microelectromechanical systems[D]. California:University of California, 1994.

IYER S V. Modeling and Simulation of Non-idealities in a Z-axis CMOS-MEMS Gyroscope[D]. Carnegie-Mellon University, 2003.

M'CLOSKEY R T, GIBSON S, HUI J. Modal parameter identification of a MEMS gyroscope[C]. American Control Conference,IEEE, 2000, 3: 1699-1704.

李锦明. 高信噪比电容式微机械陀螺的研究[D]. 太原:中北大学, 2005.

LI J M. Research on high signal-noise ratio of capacitive micromechanical gyroscope[D]. Taiyuan:North University of China, 2005. (in Chinese)

BORESI A P, SCHMIDT R J, SIDEBOTTOM O M. Advanced Mechanics of Materials[M]. New York: Wiley, 1993.

SOKOLNIKOFF I S, SPECHT R D. Mathematical theory of elasticity[M]. New York: McGraw-Hill, 1956.

Views

590

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Dynamic numerical simulation of a electromagnetic microfluidic active mixer

Related Author

LI Shu-xian

WU Yi-hui

XUAN Ming

Related Institution

State Key Lab of Applied Optics, Changchun Institute of Optics, Fine Mechanics and Physics ,Chinese Academy of Sciences

Graduate School of Chinese Academy of Sciences

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰