Modeling and analysis of magnetic field distribution for stack giant magnetostrictive actuator

Zhong-bo HE; Ce RONG; Dong-wei LI; Guang-ming XUE; Jia-wei ZHENG

doi:10.3788/OPE.20172509.2347

您当前的位置：

首页 >

文章列表页 >

Modeling and analysis of magnetic field distribution for stack giant magnetostrictive actuator

更新时间：2020-08-13

- Modeling and analysis of magnetic field distribution for stack giant magnetostrictive actuator
- Optics and Precision Engineering Vol. 25, Issue 9, Pages: 2347-2358(2017)
- 作者机构：
  
  军械工程学院车辆与电气工程系, 河北石家庄 050003
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20172509.2347
  CLC： TP271.2;TM274
- Received：10 April 2017，
  
  Accepted：22 June 2017，
  
  Published：2017-09
- 稿件说明：
移动端阅览
Zhong-bo HE, Ce RONG, Dong-wei LI, et al. Modeling and analysis of magnetic field distribution for stack giant magnetostrictive actuator[J]. Optics and precision engineering, 2017, 25(9): 2347-2358.
DOI：

Zhong-bo HE, Ce RONG, Dong-wei LI, et al. Modeling and analysis of magnetic field distribution for stack giant magnetostrictive actuator[J]. Optics and precision engineering, 2017, 25(9): 2347-2358. DOI： 10.3788/OPE.20172509.2347.

摘要

为提高超磁致伸缩致动器（GMA）偏置磁场的均匀度，设计了叠堆式超磁致伸缩致动器（SGMA），建立了SGMA的磁场分布模型，并对模型进行分析研究。首先，通过分析传统GMA偏磁施加方式的特点和不足，采用永磁体和GMM棒交替排布的结构形式，设计了SGMA；然后，将磁路模型和毕奥-萨伐尔定律相结合，建立了能够准确描述SGMA磁场特点的磁场分布模型；接着，利用所建立磁场分布模型分析了不同参数对SGMA磁场分布特征的影响，提出了SGMA结构设计方法；最后，通过实验完成了模型验证。结果表明：采用本文建立的模型描述SGMA磁场分布时，最大相对误差低于4%；在预测SGMA的输出位移时，最大相对误差低于5%。该模型有助于准确刻画SGMA的工作状态，提高SGMA的系统精度，并为SGMA结构设计提供参考依据。

Abstract

In this paper

a kind of Stack Giant Magnetostrictive Actuator (SGMA) was designed

then the magnetic field distribution model of SGMA was established

and analytical research on model was conducted to increase uniformity of bias magnetic field of GMA. Firstly

given the characteristics and drawbacks of infliction way of bias magnetic field in traditional GMA

structural form of alternative arrangement for permanent magnet and GMM rod was adopted to design SGMA. Then by combining magnetic circuit model with Biot-Savart law

magnetic distribution model can accurately describe magnetic feature of SGMA was establish. Subsequently

the influence of different parameters on magnetic field distribution feature was analyzed on established model

and structural design method of SGMA was proposed. Finally

model verification experiments were conducted. The result indicates: maximum relative error is lower than 4% when using established model to describe magnetic field distribution of SGMA; maximum relative error is lower than 5% at the time of predicting output displacement of SGMA. The established model in this paper can describe work state of SGMA accurately

increase system precision of SGMA and provide reference basis for structural design of SGMA.

关键词

Keywords

references

YANG ZH SH, HE ZH B, LI D W, et al.. Direct drive servo valve based on magnetostrictive actuator:multi-coupled modeling and its compound control strategy [J].Sensors and Actuators:Physical, 2015, 235:119-130.

LIU H F, WANG S J, ZHANG Y. Study on the giant magnetostrictive vibration-power generation method for battery-less tire pressure monitoring system [J].Journal of Mechanical Engineering Science, 2015, 229(9):1639-1651.

张雷, 邬义杰, 刘孝亮, 等.用于异形孔精密加工的超磁致伸缩构件的线性化迟滞建模[J].光学精密工程, 2012, 20(2):287-295.

ZHANG L, WU Y J, LIU X L, et al.. Linearity hysteresis model of giant magnetostrictive components for non-cylindrical hole precision mechining [J]. Opt. Precision Eng., 2012, 20(2):287-295.(in Chinese)

翟鹏, 肖博涵, 贺凯, 等.超磁致伸缩致动器的复合反馈控制及其在变椭圆销孔精密加工中的应用[J].光学精密工程, 2016, 24(6):1389-1398.

ZHAI P, XIAO B H, HE K, et al.. Composite backward control for GMA and its application in high precision mechining of variable ellipse pinhole [J]. Opt. Precision Eng., 2016, 24(6):1389-1398.(in Chinese)

贾振元, 郭东明.超磁致伸缩微位移执行器原理与应用[M].北京:科学出版社, 2008.

JIA ZH Y, GUO D M.Theory and Application of Giant Magnetostrictive Micro displacement Actuator [M]. Beijing:Science Press, 2008.(in Chinese)

XUE G M, HE ZH B, LI D W, et al.. Analysis of the giant magnetostrictive actuator with strong bias magnetic field [J].Journal of Magnetism and Magnetic Materials, 2015, 394:416-421.

SMITH R C. Inverse compensation for hysteresis in magnetostrictive transducers [R]. Center for Research in Scientific Computation Department of Mathematics, Raleigh, NC , 1998.

YANG ZH SH, HE ZH B, LI D W, et al.. Bias magnetic field of stack giant magnetostrictive actuator:design, analysis and optimization [J]. Advances in Materials Science and Engineering, 2016:1-13.

HALL D L. Dynamics and vibrations of magnetostrictive transducers [D].Ames Iowa:Iowa State University, 1994.

WANG X Y, WU J J, JIA ZH Y, et al.. Mechanical and magnetic analysis of giant magnetostrictive transducer[J]. Applied Mechanics and Materials, 2011, 79:166-171.

杨远飞, 张天丽, 蒋成保.用于GMA的新型永磁偏置闭合磁路[J].北京航空航天大学学报, 2012, 38(12):1682-1685.

YANG Y F, ZHANG T L, JIANG CH B. Novel closed magnetic circuit with permanent biased for giant magnetostrictive actuator [J]. Journal of Beijing University of Aeroautics and Astronautics, 2012, 38(12):1682-1685.(in Chinese)

ZHANG H, ZHANG T L, JIANG CH B. Design of a uniform bias magnetic field for giant magnetostrictive actuators applying triple-ring magnets [J]. Smart Materials and Structures, 2013, 22(11):115009-115014.

牟星, 唐海军, 高学绪, 等.超磁致伸缩致动器中偏置磁场的有限元模拟[J].磁性材料及器件, 2014, 45(4):6-10.

MOU X, TANG H J, GAO X X, et al.. Finite element modeling of magnetic bias field for magnetostrictive actuator [J]. Journal of Magnetic Materials and Devices, 2014, 45(4):6-10.(in Chinese)

STACHOWIAK D. The influence of magnetic bias and prestress on magnetostriction characteristics of a giant magnetostrictive actuator [J].Przeglad Elektrotechniczny, 2013, 89:233-236.

杨旭磊, 朱玉川, 费尚书, 等.超磁致伸缩电静液作动器磁场分析与优化[J].航空动力学报, 2016, 31(9):2210-2217.

YANG X L, ZHU Y CH, FEI SH SH, et al.. Magnetic field analysis and optimization of giant magnetostrictive electro-hydrostatic actuator [J]. Journal of Aerospace Power, 2016, 31(9):2210-2217.(in Chinese)

IDZIAK P, KOWALSKI K, NOWAK L, et al.. FE transient analysis of the magnetostrictive actuator [J].International Journal of Applied Electromagnetics and Mechanics, 2011, 51(s1):S81-S87.

刘慧芳, 王汉玉, 王洁, 等.精密磁致伸缩致动器的动态非线性多场耦合建模[J].光学精密工程, 2016, 24(5):1128-1137.

LIU H F, WANG H Y, WANG J, et al.. Modeling of dynamic nonlinear multi-field coupling for precision magnetostrictive actautor [J]. Opt. Precision Eng., 2016, 24(5):1128-1137.(in Chinese)

XUE G M, ZHANG P L, HE ZH B, et al.. Revised reluctance model of the axial magnetic intensity within giant magnetostrictive rod [J].Proceedings of the Institution of Mechanical Engineers Part C:Journal of Mechanial Engineering Science, 2016, 203-210:1-12.

UMENEI A E, MELIKHOV Y, JILES D C. Analytic solution for variations of magnetic fields in closed circuit:examination of deviations from the "standard" Ampere Law equation [J].IEEE Transactions on Magnetics, 2011, 47(4):734-737.

Views

615

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Design and analysis of the manned lunar vehicle for emergency with deployable structure

Design of air-bearing simulator for free-flying robot

Model predictive sliding mode control for stack giant magnetostrictive actuators

Design and fabrication of passive MEMS pressure switch

Related Author

ZOU Meng

SHEN Yan

LIANG Changchun

QI Yingchun

WANG Kang

Da-wei LI

Zhi-yuan ZHAO

Ming-yi XIA

Related Institution

Institute of Spacecraft System Engineering，China Academy of Space Technology

Key Lab for Bionics Engineering of Education Ministry，Jilin University

Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Science

University of Chinese Academy of Sciences

School of Aerospace Engineering, Xiamen University

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰