Adaptive robust control over high-performance VCM-FSM

Xian-tao LI; Xiao-pei ZHANG; Da-peng MAO; Jing-hui SUN

doi:10.3788/OPE.20172509.2428

您当前的位置：

首页 >

文章列表页 >

Adaptive robust control over high-performance VCM-FSM

Information Sciences | 更新时间：2020-08-13

- Adaptive robust control over high-performance VCM-FSM
- Optics and Precision Engineering Vol. 25, Issue 9, Pages: 2428-2436(2017)
- 作者机构：
  
  1.中国科学院长春光学精密机械与物理研究所中国科学院航空光学成像与测量重点实验室, 吉林长春, 130033
  2.美国加利福尼亚大学洛杉矶分校, 亨利·萨缪理工程和应用科学学院, 美国洛杉矶市, 希尔加德大道405
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20172509.2428
  CLC：
- Received：15 July 2016，
  
  Accepted：14 September 2016，
  
  Published：25 September 2017
- 稿件说明：
移动端阅览
Xian-tao LI, Xiao-pei ZHANG, Da-peng MAO, et al. Adaptive robust control over high-performance VCM-FSM[J]. Optics and precision engineering, 2017, 25(9): 2428-2436.
DOI：

Xian-tao LI, Xiao-pei ZHANG, Da-peng MAO, et al. Adaptive robust control over high-performance VCM-FSM[J]. Optics and precision engineering, 2017, 25(9): 2428-2436. DOI： 10.3788/OPE.20172509.2428.

摘要

为了进一步提高复合轴航空光电稳定平台的性能，文中首先在硬件电路中采用电流环将复杂的电机模型简化为一阶模型，同时保证电机的输出力矩稳定；然后在PD控制器的基础上，引入了自适应鲁棒控制器，对快速反射镜进行位置控制和扰动抑制；最后分别通过带宽测试实验、扰动抑制实验、视轴稳定实验和鲁棒性实验对其性能进行测试，并采用DOB型音圈式-快速反射镜和压电陶瓷式-快速反射镜做对比。实验结果表明：相比于传统的DOB型音圈式-快速反射镜系统，本文控制方法的参数鲁棒性更强；相比于传统的压电式-快速反射镜，本文控制方法不仅视轴稳定精度与其不相上下，还具有更大的行程。除此之外，在80 Hz以内任意频率扰动的影响下，基于ARC型音圈式-快速反射镜的复合轴航空光电稳定平台的视轴稳定精度均可以控制在5 μrad（RMS）以内；同时在-40 ℃~50 ℃的温度条件下依然可以保持该性能，远远优于DOB型音圈式-快速反射镜的效果。本文控制方法完全满足高精度航空光电稳定平台的性能要求，对提高航空光电稳定平台控制系统的抗扰动性能具有较高的实用价值。

Abstract

In order to improve the performance of the aviation photoelectrical stabilized platform

an adaptive robust control (ARC)-based VCM-FSM (voice coil mode-fast steering mirror) was proposed. Firstly

the current loop was adopted into electric circuit to simplify the complex model of motor into a first-order model and guarantee the stablity of output torque of the motor. Secondly

on the basis of conventional PD controller

ARC algorithm was introduced to control the position of VCM-FSM and restrain disturbance. Finally performance tests were conducted in bandwidth test experiment

disturbance restrain experiment

stabilization experiment of visual axis and robust experiment. As comparison

experimental results of DOB-based VCM-FSM and PCT-FSM were offered at the same time. As compared with the DOB-based VCM-FSM

parameter robust characteristic of proposed control method is stronger. Meanwhile

as compared with traditional PZT-FSM

it also exhibits longer travel range

much simpler driving circuit

and lower power consumption while the precision of LOS stability remains almost the same. Moreover

visual axis stabilization precision of ARC-based VSM-FSM within 5 μrad(RMS) can all be achieved under disturbance influence of any frequency within 80 Hz. This outstanding performance can be maintained at the temperature of -40 ℃ to 50 ℃

which is superior to the DOB-based VCM-FSM and can fulfill the requirements of a high precision aviation photoelectrical stabilized platform. Thus it has high practical value on improving anti-disturbance performance of control system for optoelectronic stabilizing platform of aviation.

关键词

Keywords

references

魏伟, 戴明, 李嘉全, 等.基于重复-自抗扰控制的航空光电稳定平台控制系统设计[J].吉林大学学报(工学版), 2015, 45(6):1924-1932.

WEI W, DAI M, LI J Q, et al.. Design of airborne opto-electric platform control system based on ADRC and repetitive control theory [J]. Journal of Jilin University(Engineering and Technology Edition), 2015, 46(6):1924-1932.(in Chinese)

彭树萍, 陈涛, 刘廷霞, 等.激光发射系统快速反射镜的光线反射过程[J].光学精密工程, 2015, 23(2):378-386.

PENG SH P, CHEN T, LIU T X, et al.. Reflection process of fast-steering mirror of laser launching system [J]. Opt. Precision Eng., 2015, 23(2):378-386.(in Chinese)

徐新行, 刘廷霞, 时魁, 等.提高万向轴系式快速反射镜指向精度的装置[J].光学精密工程, 2015, 23(6):1688-1694.

XU X H, LIU T X, SHI K, et al.. Device for improving pointing precision of fast steering mirror with spherical gemel [J]. Opt. Precision Eng., 2015, 23(6):1688-1694.(in Chinese)

魏君成, 杨永明.基于压电陶瓷直驱的前向像移补偿系统[J].液晶与显示, 2015, 30(3):519-524.

WEI J CH, YANG Y M. Forward motion compensation system based on piezoelectric direct drive [J]. Chinese Journal of Liquid Crystals and Displays, 2015, 30(3):519-524.(in Chinese)

方楚, 郭劲, 徐新行, 等.压电陶瓷驱动FSM三自由度柔性支撑设计[J].红外与激光工程, 2015, 44(10):2987-2994.

FANG CH, GUO J, XU X H, et al.. Design of three DOFs flexure support for FSM driven by piezoelectric ceramics [J]. Infrared and Laser Engineering, 2015, 44(10):2987-2994.(in Chinese)

杨明, 郝亮, 徐殿国.双惯量弹性负载系统机械谐振机理分析及谐振特征快速辨识[J].电机与控制学报, 2016, 20(4):112-120.

YANG M, HAO L, XU D G.Analysis of mechanical resonance mechanism and fast identification of resonance characteristic for 2-mass system with elastic load [J]. Electric Machines and Control, 2016, 20(4):112-120.(in Chinese)

GAO Z Q. Scaling and bandwidth-parameterization based controller tuning[C]. Proceedings of the American Control Conference , Evanston , IL:IEEE , 2003:4989-4996 http://dx.doi.org/10.1109/ACC.2003.1242516

GAO Z Q. Active disturbance rejection control: a paradigm shift in feedback control system design [C]. American Control Conference , 2006. http://ieeexplore.ieee.org/xpls/icp.jsp?arnumber=1656579

GAO Z Q, HUANG Y, HAN J Q. An alternative paradigm for control system design [C]. Proceedings of the 40th IEEE Conference on Decision and Control , 2001. http://ieeexplore.ieee.org/xpls/abs_all.jsp?arnumber=980926

李玉霞, 孟浩然, 张斌, 等.基于LabView的伺服转台Stribeck摩擦测量系统[J].液晶与显示, 2015, 30(1):180-185.

LI Y X, MENG H R, ZHANG B, et al.. Stribeck friction measure system of servo table based on Labview [J].Chinese Journal of Liquid Crystals and Displays, 2015, 30(1):180-185.(in Chinese)

克晶, 苏宝库, 曾鸣.一种直流力矩电机系统的滞滑摩擦补偿方法[J].哈尔滨工业大学学报, 2005, 37(6):736-739.

KE J, SU B K, ZENG M. Nonlinear stick-slip friction compensation for DC motors [J].Journal of Harbin Institute of Technology, 2005, 37(6):736-739.(in Chinese)

王三秀, 俞立, 徐建明, 等.机械臂自适应鲁棒轨迹跟踪控制[J].控制工程, 2015, 22(2):241-245.

WANG S X, YU L, XU J M, et al.. Adaptive robust tracking control for robotic manipulators [J]. Control Engineering of China, 2015, 22(2):241-245.(in Chinese)

唐莺, 赵建强, 胡恒江, 等.平面柔性涡流传感器工作频率影响分析与验证[J].仪表技术与传感器, 2015(8):4-6.

TANG Y, ZHAO J Q, HU H J, et al.. Analysis and validation of effect of frequency on planar eddy sensor [J]. Instrument Technique and Sensor, 2015(8):4-6.(in Chinese)

汪永阳, 戴明, 丁策, 等.光电稳定平台中高阶扰动观测器的应用[J].光学精密工程, 2015, 23(2):459-466.

WANG Y Y, DAI M, DING C, et al.. Application of order observer in EO stabilized platform [J]. Opt. Precision Eng., 2015, 23(2):459-466.(in Chinese)

胡异丁, 任伟新, 颜健毅, 等. Hilbert低通滤波器特性分析及改进数值计算方法[J].振动、测试与诊断, 2016, 36(2):383-389+408.

HU Y D, REN W X, YAN J Y, et al.. Analysis of characteristic of hilbert low-pass filter and improved numerical calculated method [J]. Journal of Vibration, Measurement & Diagnosis, 2016, 36(2):383-389+408.(in Chinese)

黄莎莎, 乔嘉, 王赞超.动平台光电跟踪测量系统在飞行试验中的应用研究[J].中国科技信息, 2015(7):16-18.

HUANG SH SH, QIAO J, WANG Z CH.Application of moving platform electro-optical tracking measurement system in flight trials [J].China Science and Technology Information, 2015(7):16-18.(in Chinese)

Views

666

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Improvement of isolation degree of aerial photoelectrical stabilized platform based on ADRC

Related Author

LI Xian-tao

ZHANG Bao

SHEN Hong-hai

Related Institution

University of Chinese Academy of Sciences

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰