Structure and performance of rotating piezoelectric generator with tunable frequency

Jun-wu KAN; Heng-qian HE; Shu-yun WANG; Zhong-hua ZHANG; Song CHEN; Ze-feng CHEN

doi:10.3788/OPE.20192703.0577

您当前的位置：

首页 >

文章列表页 >

Structure and performance of rotating piezoelectric generator with tunable frequency

Micro/Nano Technology and Fine Mechanics | 更新时间：2020-08-13

- Structure and performance of rotating piezoelectric generator with tunable frequency
- Optics and Precision Engineering Vol. 27, Issue 3, Pages: 577-583(2019)
- 作者机构：
  
  浙江师范大学精密机械与智能结构研究所，浙江金华 321004
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20192703.0577
  CLC： TN384; TM619
- Received：16 July 2018，
  
  Accepted：12 September 2018，
  
  Published：15 March 2019
- 稿件说明：
移动端阅览
Jun-wu KAN, Heng-qian HE, Shu-yun WANG, et al. Structure and performance of rotating piezoelectric generator with tunable frequency[J]. Optics and precision engineering, 2019, 27(3): 577-583.
DOI：

Jun-wu KAN, Heng-qian HE, Shu-yun WANG, et al. Structure and performance of rotating piezoelectric generator with tunable frequency[J]. Optics and precision engineering, 2019, 27(3): 577-583. DOI： 10.3788/OPE.20192703.0577.

摘要

为提高旋转式压电发电机的安全性与有效带宽，提出一种可调频旋磁激励式压电发电机，并从理论、仿真与试验三个方面对发电机的工作特性进行了研究。建立了压电梁在端部外载荷作用下的刚度/频率偏移模型，并通过仿真获得了刚度、动磁铁数量对发电机响应特性的影响规律。结果表明，压电梁刚度随端部拉/压力的增大而线性增大/减小，固有频率相应地提高且趋于平缓/降低且速率增大，而动磁铁数量将影响发电机的谐振峰数量与放大比。在此基础上进行了相关试验，试验表明，压电梁受拉伸/压缩都将提高发电机的固有频率并降低输出电压幅值，且受压时减幅更大；此外，动磁铁数量除仿真中影响因素外对发电机的固有频率也具有一定影响；通过改变动磁铁数量与调节量，实现了发电机固有频率在39.2~112 Hz内的调整，最大频率偏移为185.7%。

Abstract

To improve the security of a rotary piezoelectric generator and broaden the effective frequency band

a rotating piezoelectric generator with tunable frequency was studied and its performance was evaluated through theoretical analysis

simulations

and experiments. Natural frequency offset and stiffness offset models were first established

and the effects of stiffness and the number of rotating magnets on the response performance of a generator were determined through a simulation. The analytical results show that the stiffness of the generator linearly increased with axial tension and linearly decreased with axial compression. In addition

the natural frequency increased and became steady with axial tension but decreased at a fast rate with axial compression. Based on the fact that the number of rotating magnets affects the number of resonant peaks as well as the amplitude ratio of the generator

a prototype rotating piezoelectric generator was fabricated and tested. The test results reveal that the natural frequency of the generator increases and that generated voltage decreases depending on whether the piezoelectric beam is stretched or compressed

with the latter having a greater influence on voltage reduction. In addition

the number of rotating magnets affects the natural frequency of the generator. By changing the number of rotating magnets and conducting pre-stretching and pre-compression

the natural frequency of the generator can be adjusted to within a range of 39.2-112 Hz with a maximum frequency shift of 185.7%.

关键词

Keywords

references

程廷海, 刘文博, 赵宏伟, 等.气动高压激励的阵列式盘型压电俘能器[J].光学精密工程, 2017, 25(5):1222-1228.

CHENG T H, LIU W B, ZHAO H W, et al .. Array piezoelectric plate harvester excited by pneumatic compressed air[J]. Opt. Precision Eng. , 2017, 25(5):1222-1228. (in Chinese)

阚君武, 富佳伟, 王淑云, 等.涡激振动式微型流体俘能器的研究现状与展望[J].光学精密工程, 2017, 25(6):1502-1512.

KAN J W, FU J W, WANG SH Y, et al .. Research status and prospect of vortex-induced vibration micro-fluid energy harvester[J]. Opt. Precision Eng., 2017, 25(6):1502-1512. (in Chinese)

CUI Y, ZHANG Q, YAO M, et al .. Vibration piezoelectric energy harvester with multi-beam[J]. AIP Advances , 2015, 5(4):4495-4498.

WEI C, JING X. A comprehensive review on vibration energy harvesting: Modelling and realization[J]. Renewable & Sustainable Energy Reviews , 2017, 74:1-18.

PILLATSCH P, YEATMAN E M, HOLMES A S. Real world testing of a piezoelectric rotational energy harvester for human motion[J]. J. Phys.: Conf. Ser., 2013,476: 012010.

KUANG Y, YANG Z, ZHU M. Design and characterisation of a piezoelectric knee-joint energy harvester with frequency up-conversion through magnetic plucking[J]. Smart Materials and Structures , 2016, 25(8):085029.

VIET N V, AL-QUTAYRI M, LIEW K M, et al .. An octo-generator for energy harvesting based on the piezoelectric effect[J]. Applied Ocean Research , 2017, 64:128-134.

FU H, YEATMAN E M. A methodology for low-speed broadband rotational energy harvesting using piezoelectric transduction and frequency up-conversion[J]. Energy , 2017,125: 152-161.

ZHAO L, YANG Y. Toward small-scale wind energy harvesting: design, enhancement, performance comparison and applicability[J]. Shock and Vibration , 2017(4):3585972.

TAO J X, VIET N V, CARPINTERI A, et al .. Energy harvesting from wind by a piezoelectric harvester[J]. Engineering Structures , 2017,133:74-80.

ZOU H X, ZHANG W M, LI W B, et al .. Design and experimental investigation of a magnetically coupled vibration energy harvester using two inverted piezoelectric cantilever beams for rotational motion[J]. Energy Conversion & Management , 2017,148:1391-1398.

ZHANG J, FANG Z, SHU C, et al .. A rotational piezoelectric energy harvester for efficient wind energy harvesting[J]. Sensors & Actuators A Physical , 2017,262: 123-129.

ZHANG H, JIANG S, HE X. Impact-based piezoelectric energy harvester for multidimensional, low-level, broadband, and low-frequency vibrations[J]. Applied Physics Letters , 2017,110(22):18-27.

KAN J, FU J, WANG S, et al .. Study on a piezo-disk energy harvester excited by rotary magnets[J]. Energy , 2017,122:62-69.

JUNG H J, BAEK K H, HIDAKA S, et al .. Design and optimization of secondary shock type piezoelectric system[C]. Isaf-Ecapd-Pfm., IEEE , 2012: 1-4.

ZHANG Y, ZHENG R, NAKANO K, et al .. Stabilising high energy orbit oscillations by the utilisation of centrifugal effects for rotating-tyre-induced energy harvesting[J]. Applied Physics Letters , 2018,112(14): 143901.

阚君武, 于丽, 王淑云, 等.旋磁激励式压电悬臂梁发电机性能分析与试验[J].机械工程学报, 2014, 50(8):144-149.

KAN J W, YU L, WANG SH Y, et al .. Performance analysis and test of piezo-cantilever generator excited by rotary magnet[J]. Opt. Precision Eng., 2014, 50(8):144-149. (in Chinese)

MORRIS D J, YOUNGSMAN J M, ANDERSON M J, et al .. A resonant frequency tunable, extensional mode piezoelectric vibration harvesting mechanism[J]. Smart Materials & Structures , 2008, 17(6):065021.

PETERS C, MAURATH D, SCHOCK W, et al .. A closed-loop wide-range tunable mechanical resonator for energy harvesting systems[J]. Journal of Micromechanics & Microengineering , 2009, 19(9):094004.

CHALLA V R, PRASAD M G, FISHER F T. Towards an autonomous self-tuning vibration energy harvesting device for wireless sensor network applications[J]. Smart Materials & Structures , 2011, 20(2):25004-25011.

刘鸿文.高等材料力学[M].北京:高等教育出版社, 1985.

LIU H W. Advanced Material Mechanics [M]. Beijing: Higher Education Press, 1985. (in Chinese)

Views

159

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰