Design of high-accuracy laser beam collimation system

Fan ZHU; Ying-xian LI; Jiu-bin TAN

doi:10.3788/OPE.20202804.0817

您当前的位置：

首页 >

文章列表页 >

Design of high-accuracy laser beam collimation system

Modern Applied Optics | 更新时间：2020-08-13

- Design of high-accuracy laser beam collimation system
- Optics and Precision Engineering Vol. 28, Issue 4, Pages: 817-826(2020)
- 作者机构：
  
  哈尔滨工业大学超精密光电仪器工程研究所，黑龙江哈尔滨 150080
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20202804.0817
  CLC： TH741.14; TP391
- Received：30 October 2019，
  
  Revised：10 December 2019，
  
  Accepted：10 December 2019，
  
  Published：15 April 2020
- 稿件说明：
移动端阅览
Fan ZHU, Ying-xian LI, Jiu-bin TAN. Design of high-accuracy laser beam collimation system[J]. Optics and precision engineering, 2020, 28(4): 817-826.
DOI：

Fan ZHU, Ying-xian LI, Jiu-bin TAN. Design of high-accuracy laser beam collimation system[J]. Optics and precision engineering, 2020, 28(4): 817-826. DOI： 10.3788/OPE.20202804.0817.

摘要

为了进一步提高激光光束用作直线基准的精度，建立了基于反射镜平动式光束稳定器以及两点式光束漂移分离法的高精度激光光束准直系统。首先，对系统中基于反射镜平动的光束稳定器进行研究，对其光束偏转原理以及影响因素进行分析，并对两点式光束漂移分离方法进行介绍。然后，对光束偏转单元的分辨力以及偏转范围、所使用的压电陶瓷非线性和迟滞特性、以及光束偏转单元的频率响应特性进行实验测试。最后，对该激光准直系统的激光光束准直精度进行测试。实验结果表明：本文提出的光束偏转单元在120 μrad范围内的光束偏转分辨力可以达到5 nrad，频率响应特性高于2 kHz；最终激光准直系统的准直精度在二维方向上分别达到1.9×10

-8

rad和2.1×10

-8

rad

相对于现有技术约提高了3倍，满足激光光束用作高精度直线基准的需求。

Abstract

To further improve the accuracy of laser-beam linear datum

a high-accuracy laser collimation system based on a high resolution and high frequency response beam stabilizer and a two-point beam drift separation method was established in this study. First

the translation mirror-based beam stabilizer of the system was studied

and its beam deflection principle and influence factor were analyzed in addition with the two-point beam drift separation method. Then

the resolution and deflection ranges of beam stabilizer

the nonlinearity and hysteresis of piezo

and the associated frequency response were tested. Finally

experimental tests were conducted to determine the accuracy of the laser collimation system. Experimental results indicate that a resolution of 5 nrad of the beam stabilizer can be achieved in deflection range of 120 μrad with frequency response higher than 2 kHz. Furthermore

accuracies of 1.9×10

-8

rad and 2.1×10

-8

rad of the laser-beam collimation system in 2D directions are obtained

which are both 3 times higher than those corresponding to existing technology. The investigated system is

therefore

capable of satisfying the high accuracy requirements of linear datum using laser-beam.

关键词

Keywords

references

H S YANG , S W KIM , D WALKER . Novel laser datum system for nanometric profilometry for large optical surfaces . Optics Express , 2003 . 11 ( 6 ): 624 - 631 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000001653269 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000001653269 .

D WALKER , H S YANG , S W KIM . Novel hybrid stylus for nanometric profilometry for large optical surfaces . Optics Express , 2003 . 11 ( 15 ): 1793 - 1798 . http://d.old.wanfangdata.com.cn/NSTLQK/10.1364-OE.11.001793/ http://d.old.wanfangdata.com.cn/NSTLQK/10.1364-OE.11.001793/ .

K W WANG , L J ZENG , C Y YIN . Influence of the incident wave-front on intensity distribution of the nondiffracting beam used in large-scale measurement . Optics Communications , 2003 . 216 ( 1 ): 99 - 103 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=fa12b9b4e55d5a5eadf5cfff19c3ec59 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=fa12b9b4e55d5a5eadf5cfff19c3ec59 .

W Q ZHAO , J B TAN , L R QIU , 等 . Enhancing laser beam directional stability by single-mode optical fiber and feedback control of drifts . Review of Scientific Instruments , 2005 . 76 ( 3 ): 036101 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=e042e01846ab47340b218d44c2262f7a http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=e042e01846ab47340b218d44c2262f7a .

W Q ZHAO , L R QIU , Z D FENG , 等 . Laser beam alignment by fast feedback control of both linear and angular drifts . Optik , 2006 . 117 ( 11 ): 505 - 510 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=1a555619868da39804407233b6e14777 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=1a555619868da39804407233b6e14777 .

J UCHIKOSHI , S SHIMADA , N IKAWA , 等 . Straightness measurement using laser beam straight datum . SPIE, 1995 , 2576 . 315 - 322 . http://d.old.wanfangdata.com.cn/NSTLHY/NSTL_HYCC026094616/ http://d.old.wanfangdata.com.cn/NSTLHY/NSTL_HYCC026094616/ .

杨飞 , 安其昌 , 张静 , 等 . 大口径光学系统的镜面视宁度检测 . 光学精密工程 , 2017 . 25 ( 10 ): 2572 - 2579 . http://www.eope.net/CN/abstract/abstract17251.shtml http://www.eope.net/CN/abstract/abstract17251.shtml .

F YANG , Q CH AN , J ZHANG , 等 . Seeing metrology of large aperture mirror of telescope . Opt. Precision Eng , 2017 . 25 ( 10 ): 2572 - 2579 . http://www.eope.net/CN/abstract/abstract17251.shtml http://www.eope.net/CN/abstract/abstract17251.shtml .

朱凡 , 谭欣然 , 谭久彬 , 等 . 高分辨力与高输出稳定性自准直系统设计 . 光学精密工程 , 2016 . 24 ( 10 ): 109 - 116 . http://www.eope.net/CN/abstract/abstract16617.shtml http://www.eope.net/CN/abstract/abstract16617.shtml .

F ZHU , X R TAN , J B TAN , 等 . Design of high resolution and output stability autocollimation system . Opt. Precision Eng , 2016 . 24 ( 10 ): 109 - 116 . http://www.eope.net/CN/abstract/abstract16617.shtml http://www.eope.net/CN/abstract/abstract16617.shtml .

方仲彦 , 殷纯永 , 梁晋文 . 高精度激光准直技术的研究(二) . 航空计测技术 , 1997 . 17 ( 2 ): 6 - 8, 15 . http://d.old.wanfangdata.com.cn/Conference/40385 http://d.old.wanfangdata.com.cn/Conference/40385 .

ZH Y FANG , CH Y YIN , J W LIANG . Study on high accuracy laser alignment technique . Aviation Metrology & Measurement Technology , 1997 . 17 ( 2 ): 6 - 8, 15 . http://d.old.wanfangdata.com.cn/Conference/40385 http://d.old.wanfangdata.com.cn/Conference/40385 .

D LUO , C F KUANG , X HAO , 等 . High-precision laser alignment technique based on spiral phase plate . Optics and Lasers in Engineering , 2012 . 50 ( 7 ): 944 - 949 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=970247f02e23e31c59781cc7383d95cd http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=970247f02e23e31c59781cc7383d95cd .

Q HAO , D C LI , Y T WANG . High-accuracy long distance alignment using single-mode optical fiber and phase plate . Optics and Laser Technology , 2002 . 34 ( 4 ): 287 - 292 . http://d.old.wanfangdata.com.cn/NSTLQK/NSTL_QKJJ024413246/ http://d.old.wanfangdata.com.cn/NSTLQK/NSTL_QKJJ024413246/ .

C F KUANG , Q B FENG , B ZHANG , 等 . A four-degree-of-freedom laser measurement system (FDMS) using a single-mode fiber-coupled laser module . Sensors and Actuators A-physical , 2005 . 125 ( 1 ): 100 - 108 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=3e6d360f7776e6c396d2055c0a2d9c6e http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=3e6d360f7776e6c396d2055c0a2d9c6e .

Q B FENG , B ZHANG , C F KUANG . A straightness measurement system using a single-mode fiber-coupled laser module . Optics & Laser Technology , 2004 . 36 ( 4 ): 279 - 283 . http://d.old.wanfangdata.com.cn/NSTLQK/10.1016-j.optlastec.2003.09.016/ http://d.old.wanfangdata.com.cn/NSTLQK/10.1016-j.optlastec.2003.09.016/ .

https://www.physikinstrumente.com/en/products/linear-actuators/nanopositioning-piezo-actuators/p-820-preloaded-piezo-actuators-100500/#specification. https://www.physikinstrumente.com/en/products/linear-actuators/nanopositioning-piezo-actuators/p-820-preloaded-piezo-actuators-100500/#specification.

SHEN G, GAYHART A R, EATON D J, et al .. Large-angle fast-steering mirrors[C]. San Diego , '91. Proc SPIE 1543, Active and Adaptive Optical Components , San Diego , CA , USA , 1992: 286-293.

L R HEDDING , R A LEWIS . Fast steering mirror design and performance for stabilization and single axis scanning . SPIE, 1990 , 1304 . 14 - 24 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=CC026539725 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=CC026539725 .

L M GERMANN , J BRACCIO . Fine-steering mirror technology supports 10 nanoradian systems . Optical Engineering , 1990 . 29 ( 11 ): 1351 - 1359 . http://cn.bing.com/academic/profile?id=640ed41f589d45b30f45290dc0289524&encoded=0&v=paper_preview&mkt=zh-cn http://cn.bing.com/academic/profile?id=640ed41f589d45b30f45290dc0289524&encoded=0&v=paper_preview&mkt=zh-cn .

G Y SHEN , A R GAYHART , D J EATON , 等 . Large-angle fast-steering mirrors . SPIE , 1992 . 1543 286 - 293 . http://d.old.wanfangdata.com.cn/NSTLHY/NSTL_HYCC025728303/ http://d.old.wanfangdata.com.cn/NSTLHY/NSTL_HYCC025728303/ .

X WU , S H CHEN , B Y SHI , 等 . High-powered voice coil actuator for fast steering mirror . Optical Engineering , 2011 . 50 ( 2 ): 023002 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=8d00381273629c850038817223207406 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=8d00381273629c850038817223207406 .

M N SWEENEY , G A RYNKOWSKI , M KETABCHI , 等 . Design considerations for fast-steering mirrors (FSMs) . SPIE , 2002 . 4773 63 - 73 . http://d.old.wanfangdata.com.cn/NSTLQK/10.1117-12.469197/ http://d.old.wanfangdata.com.cn/NSTLQK/10.1117-12.469197/ .

V V NIKULIN , M BOUZOUBAA , V A SKORMIN , 等 . Modeling of an acousto-optic laser beam steering system intended for satellite communication . Optical Engineering , 2001 . 40 ( 10 ): 2208 - 2214 . http://d.old.wanfangdata.com.cn/NSTLQK/10.1117-1.1403022/ http://d.old.wanfangdata.com.cn/NSTLQK/10.1117-1.1403022/ .

D A PINNOW . Acousto-optic light deflection: design considerations for first order beam steering transducers . IEEE Transactions on Sonics and Ultrasonics , 1971 . 18 ( 4 ): 209 - 214 . http://cn.bing.com/academic/profile?id=d2f3e292a7d756f3162e1e7205d867c8&encoded=0&v=paper_preview&mkt=zh-cn http://cn.bing.com/academic/profile?id=d2f3e292a7d756f3162e1e7205d867c8&encoded=0&v=paper_preview&mkt=zh-cn .

R BARBOZA , A ALBERUCCI , G ASSANTO . Large electro-optic beam steering with nematicons . Optics Letters , 2011 . 36 ( 14 ): 2725 - 2727 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=d9e25a7596294a803e4a7df9c38ba104 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=d9e25a7596294a803e4a7df9c38ba104 .

D A SCRYMGEOUR , Y BARAD , V GOPALAN , 等 . Large-angle electro-optic laser scanner on LiTaO3 fabricated by in situ monitoring of ferroelectric-domain micropatterning . Applied Optics , 2001 . 40 ( 34 ): 6236 - 6241 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=4a77ef3bc0d0a1587fa48a61f6bb8036 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=4a77ef3bc0d0a1587fa48a61f6bb8036 .

D ENGSTROM , M J OCALLAGHAN , C K WALKER , 等 . Fast beam steering with a ferroelectric-liquid-crystal optical phased array . Applied Optics , 2009 . 48 ( 9 ): 1721 - 1726 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=5a11bee099f495b7474b454ff157c980 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=5a11bee099f495b7474b454ff157c980 .

A LIZANA , A MARQUEZ , L LOBATO , 等 . The minimum Euclidean distance principle applied to improve the modulation diffraction efficiency in digitally controlled spatial light modulators . Optics Express , 2010 . 18 ( 10 ): 10581 - 10593 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000002400807 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000002400807 .

R J BECK , J P PARRY , W N MACPHERSON , 等 . Application of cooled spatial light modulator for high power nanosecond laser micromachining . Optics Express , 2010 . 18 ( 16 ): 17059 - 17065 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000000273649 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000000273649 .

J L GIBSON , B D DUNCAN , P BOS , 等 . Wide angle beam steering for Infrared Countermeasures applications . SPIE, 2002 , 4723 . 100 - 111 . http://cn.bing.com/academic/profile?id=3618511b7a17e38d9e39a5b0b7542b7e&encoded=0&v=paper_preview&mkt=zh-cn http://cn.bing.com/academic/profile?id=3618511b7a17e38d9e39a5b0b7542b7e&encoded=0&v=paper_preview&mkt=zh-cn .

A AKATAY , H UREY . Design and optimization of microlens array based high resolution beam steering system . Optics Express , 2007 . 15 ( 8 ): 4523 - 4529 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000000668139 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000000668139 .

J BOURDERIONNET , M RYNGENHAGEN , D DOLFI , 等 . Continuous laser beam steering with micro-optical arrays: experimental results . SPIE , 2008 . 7113 1 - 11 . http://cn.bing.com/academic/profile?id=6845d7c9deed00e8f0c3a81322dc2293&encoded=0&v=paper_preview&mkt=zh-cn http://cn.bing.com/academic/profile?id=6845d7c9deed00e8f0c3a81322dc2293&encoded=0&v=paper_preview&mkt=zh-cn .

A AKATAY , A WADDIE , H SUYAL , 等 . Comparative performance analysis of 100% fill-factor microlens arrays fabricated by various methods . SPIE , 2006 . 61850C 1 - 11 . https://www.researchgate.net/profile/Hakan_Urey/publication/269317742_Comparative_performance_analysis_of_100_fill-factor_microlens_arrays_fabricated_by_various_methods/links/555ef1a708ae6f4dcc8df770.pdf?inViewer=true&disableCoverPage=true&origin=publication_detail https://www.researchgate.net/profile/Hakan_Urey/publication/269317742_Comparative_performance_analysis_of_100_fill-factor_microlens_arrays_fabricated_by_various_methods/links/555ef1a708ae6f4dcc8df770.pdf?inViewer=true&disableCoverPage=true&origin=publication_detail .

N SMITH , D C ABEYSINGHE , J W HAUS , 等 . Agile wide-angle beam steering with electrowetting microprisms . Optics Express , 2006 . 14 ( 14 ): 6557 - 6563 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000000193906 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=Open J-Gate000000193906 .

SMITH N R. Investigation of the performance potential for arrayed electrowetting microprisms [D]. Dissertations & Theses - Gradworks, University of Cincinnati, 2009: 1-7.

Views

655

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Suppression of effects of air random disturbances in laser collimation measurements

Accuracy improvement method and optimal design of straightness in five-degree-of-freedom measurement of long guide

Automatic compensation method for beam drift in long-distance laser measurement

Two-dimensional rotation angle dynamic measurement system combining laser collimation

Coaxiality measurement method based on revising aberration

Related Author

LIU Xiaojun

DIAO Kuan

ZHAO Haiyu

WANG Xinxing

FU Xiao

DUAN Fajie

LIU Wenzheng

ZHANG Cong

Related Institution

School of Mechanical Science and Engineering， Huazhong University of Science and Technology

State Key Laboratory of Precision Measuring Technology & Instruments， Tianjin University

College of Mechanical Engineering, Dalian University of Technology

Shanghai Academy of Sciences

Department of Instrument Science and Engineering, Shanghai Jiao Tong University

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰