Current harmonic suppression of permanent magnet synchronous linear motorbased on reduced-order double closed-loop ADRC

Ming LI; Yue-peng HU; Zhen WANG

doi:10.3788/OPE.20202805.1055

您当前的位置：

首页 >

文章列表页 >

Current harmonic suppression of permanent magnet synchronous linear motorbased on reduced-order double closed-loop ADRC

Micro/Nano Technology and Fine Mechanics | 更新时间：2020-07-09

- Current harmonic suppression of permanent magnet synchronous linear motorbased on reduced-order double closed-loop ADRC
- Optics and Precision Engineering Vol. 28, Issue 5, Pages: 1055-1065(2020)
- 作者机构：
  
  1.安徽大学电气工程与自动化学院，安徽合肥 230601
  2.合肥工业大学电气与自动化工程学院，安徽合肥 230009
- 作者简介：
- 基金信息：
- DOI：10.3788/OPE.20202805.1055
  CLC： TM359.4
- Received：22 November 2019，
  
  Revised：13 January 2020，
  
  Accepted：13 January 2020，
  
  Published：15 May 2020
- 稿件说明：
移动端阅览
Ming LI, Yue-peng HU, Zhen WANG. Current harmonic suppression of permanent magnet synchronous linear motorbased on reduced-order double closed-loop ADRC[J]. Optics and precision engineering, 2020, 28(5): 1055-1065.
DOI：

Ming LI, Yue-peng HU, Zhen WANG. Current harmonic suppression of permanent magnet synchronous linear motorbased on reduced-order double closed-loop ADRC[J]. Optics and precision engineering, 2020, 28(5): 1055-1065. DOI： 10.3788/OPE.20202805.1055.

摘要

永磁同步直线电机由于反电势和逆变器频繁切换导致电流谐波分量较大，同时参数时变以及负载突变等扰动严重影响伺服系统的控制精度。本文采用一种基于降阶状态观测器的双环自抗扰伺服控制算法，以降低控制系统的谐波抑制从而提高控制精度。首先，构造了位置速度环级联的二阶自抗扰控制器。运用极点配置法对三阶线性状态观测器进行降阶，减小了相位滞后的影响，提高了伺服系统的控制精度；其次，电流环采用一阶非线性自抗扰控制器，消除了积分饱和的影响，降低了三相电流的谐波含量。最后，与基于自抗扰控制的其他优化算法进行对比，实验表明：在多工况下降阶双环自抗扰控制的总谐波失真不超过2.13%，推力波动可减小至1.49%，稳态误差不大于15

m。

Abstract

The current harmonic components of permanent magnet synchronous linear motors are high due to back electromotive force and frequent switching of inverters. Moreover

disturbances such as time-varying parameters and sudden load changes seriously affect the control accuracy of servo systems. Therefore

a double closed-loop active disturbance rejection servo control algorithm

based on a reduced-order state observer

was presented to improve the harmonic suppression and control precision of control systems. First

the second-order active disturbance rejection controller of a position-speed loop was constructed. The pole placement method was used to reduce the order of the third-order linear extended state observer. This operation reduced the influence of phase lag and improves the control precision of the servo system. Second

the current loop first-order nonlinear active disturbance rejection controller was employed to eliminate the influence of integral saturation and reduce the harmonic content of the three-phase current. Finally

compared with other optimization algorithms based on active disturbance rejection control (ADRC)

the experiments show that the THD of reduced-order double closed-loop ADRC is less than 2.13%

the thrust fluctuation can be reduced to 1.49%

and the steady-state error is less than 15

m under multiple conditions.

关键词

Keywords

references

Z B PAN , F DONG , J W ZHAO , 等 . Combined resonant controller and two-degree-of-freedom PID controller for PMSLM current harmonics suppression . IEEE Transactions on Industrial Electronics , 2018 . 65 ( 9 ): 7558 - 7568 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=c7c605c1cc8bd800ca6abab0ccd23ae5 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=c7c605c1cc8bd800ca6abab0ccd23ae5 .

赵吉文 , 宫凯歌 , 赵静 , 等 . 基于非周期正弦条纹的直线电机动子位置测量 . 光学精密工程 , 2019 . 27 ( 4 ): 889 - 900 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201904016 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201904016 .

J W ZHAO , K G GONG , J ZHAO , 等 . Position measurement for linear motor mover based on aperiodic sinusoidal stripe image . Opt. Precision Eng. , 2019 . 27 ( 4 ): 889 - 900 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201904016 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201904016 .

张刚 , 刘品宽 , 张波 , 等 . 直线电机精密运动平台轨迹跟踪控制器设计 . 光学精密工程 , 2013 . 21 ( 2 ): 371 - 379 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201302018 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201302018 .

G ZHANG , P K LIU , B ZHANG , 等 . Design of trajectory tracking controller for precision positioning table driven by linear motor . Opt. Precision Eng. , 2013 . 21 ( 2 ): 371 - 379 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201302018 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201302018 .

Y H YANG , K L ZHOU , H WANG , 等 . Analysis and mitigation of dead-time harmonics in the single-phase full-bridge PWM converter with repetitive controllers . IEEE Transactions on Industry Applications , 2018 . 54 ( 5 ): 5343 - 5354 . http://eprints.gla.ac.uk/160737/ http://eprints.gla.ac.uk/160737/ .

Y ZHAO , W QIAO , L WU . Dead-time effect analysis and compensation for a sliding-mode position observer-basedsensorless IPMSM control system . IEEE Transactions on Industry Applications , 2015 . 51 ( 3 ): 2528 - 2535 . https://ieeexplore.ieee.org/stamp/stamp.jsp?tp=&arnumber=6963459 https://ieeexplore.ieee.org/stamp/stamp.jsp?tp=&arnumber=6963459 .

齐昕 , 吴文昊 , 吴琳 , 等 . 基于时间辅助信息的感应电机预测电流控制 . 中国电机工程学报 , 2019 . 39 ( 16 ): 4927 - 4934, 4995 .

X QI , W H WU , L WU , 等 . Predictive current control of induction machines based on time auxiliary information . Proceedings of the CSEE , 2019 . 39 ( 16 ): 4927 - 4934, 4995 .

林健 , 刘晗 , 万其 , 等 . 基于ESO的PMSLM无差拍电流预测控制 . 微电机 , 2019 . 52 ( 7 ): 52 - 55, 71 . http://d.old.wanfangdata.com.cn/Periodical/wdj201907010 http://d.old.wanfangdata.com.cn/Periodical/wdj201907010 .

J LIN , H LIU , Q WAN , 等 . Deadbeat predictive current control of PMSLM based on ESO . Micromotors , 2019 . 52 ( 7 ): 52 - 55, 71 . http://d.old.wanfangdata.com.cn/Periodical/wdj201907010 http://d.old.wanfangdata.com.cn/Periodical/wdj201907010 .

王立俊 , 赵吉文 , 董菲 , 等 . 基于自适应内模观测器的永磁同步直线电机高带宽强鲁棒预测电流控制策略研究 . 中国电机工程学报 , 2019 . 39 ( 10 ): 3098 - 3107 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201910030 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201910030 .

L J WANG , J W ZHAO , F DONG , 等 . High-bandwidth and strong robust predictive current control strategy research for permanent-magnet synchronous linear motor based on adaptive internal model observer . Proceedings of the CSEE , 2019 . 39 ( 10 ): 3098 - 3107 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201910030 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201910030 .

C J LIU , F BLAABJERG , W J CHEN , 等 . Stator current harmonic control with resonant controller for doubly fed induction generator . IEEE Transactions on Power Electronics , 2012 . 27 ( 7 ): 3207 - 3220 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=3ea19f3bdff0ee04e227d3a009507af0 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=3ea19f3bdff0ee04e227d3a009507af0 .

C PENG , JJ SUN , X D SONG , 等 . Frequency-varying current harmonics for active magnetic bearing via multiple resonant controllers . IEEE Transactions on Industrial Electronics , 2017 . 64 ( 1 ): 517 - 526 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=8d41deb3b69a3bd1ebfb70515a062aca http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=8d41deb3b69a3bd1ebfb70515a062aca .

J Q HAN . From PID to active disturbance rejection control . IEEE Transactions on Industrial Electronics , 2009 . 56 ( 3 ): 900 - 906 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=82f21f04243ab4e767b5c738ca671907 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=82f21f04243ab4e767b5c738ca671907 .

张明月 , 杨洪波 , 章家保 , 等 . 改进自抗扰控制谐波式电动舵机伺服系统 . 光学精密工程 , 2014 . 22 ( 1 ): 99 - 108 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201401016 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201401016 .

M Y ZHANG , H B YANG , J B ZHANG , 等 . Servo system of harmonic drive electromechanical actuator using improved ADRC . Opt. Precision Eng. , 2014 . 22 ( 1 ): 99 - 108 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201401016 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201401016 .

左月飞 , 张捷 , 刘闯 , 等 . 基于自抗扰控制的永磁同步电机位置伺服系统一体化设计 . 电工技术学报 , 2016 . 31 ( 11 ): 51 - 58 . http://d.old.wanfangdata.com.cn/Periodical/dgjsxb201611006 http://d.old.wanfangdata.com.cn/Periodical/dgjsxb201611006 .

Y F ZUO , J ZHANG , CH LIU , 等 . Integrated design for permanent magnet synchronous motor servo systems based on active disturbance rejection control . Transactions of China Electrotechnical Society , 2016 . 31 ( 11 ): 51 - 58 . http://d.old.wanfangdata.com.cn/Periodical/dgjsxb201611006 http://d.old.wanfangdata.com.cn/Periodical/dgjsxb201611006 .

周涛 . 永磁同步电机调速系统的自抗扰控制 . 光学精密工程 , 2016 . 24 ( 3 ): 582 - 589 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201603016 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201603016 .

T ZHOU . Activedisturbance rejection control of speed governing system for PMSM . Opt. Precision Eng. , 2016 . 24 ( 3 ): 582 - 589 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201603016 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201603016 .

奚静思 , 刘品宽 , 丁汉 . 自适应线性自抗扰控制器的设计 . 光学精密工程 , 2018 . 26 ( 7 ): 1749 - 1757 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201807021 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201807021 .

J S XI , P K LIU , H DING . Design of an adaptive linear active disturbance rejection controller . Opt. Precision Eng. , 2018 . 26 ( 7 ): 1749 - 1757 . http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201807021 http://d.old.wanfangdata.com.cn/Periodical/gxjmgc201807021 .

A BENRABAH , D G XU , Z Q GAO . Active disturbance rejection control of LCL-filtered grid-connected inverter usingpadé approximation . IEEE Transactions on Industry Applications , 2018 . 54 ( 6 ): 6179 - 6189 .

G Y SUN , Y L LI , W JIN , 等 . A nonlinear three-phase phase-locked loop based on linear active disturbance rejection controller . IEEE Access , 2017 . 5 21548 - 21556 . https://ieeexplore.ieee.org/document/8064620 https://ieeexplore.ieee.org/document/8064620 .

李杰 , 齐晓慧 , 夏元清 , 等 . 线性/非线性自抗扰切换控制方法研究 . 自动化学报 , 2016 . 42 ( 2 ): 202 - 212 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zdhxb201602004 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zdhxb201602004 .

J LI , X H QI , Y Q XIA , 等 . On linear/nonlinear active disturbance rejection switching control . Acta Automatica Sinica , 2016 . 42 ( 2 ): 202 - 212 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zdhxb201602004 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zdhxb201602004 .

GAO Z Q. Scaling and bandwidth-parameterization based controller tuning[C]. Proceedings of the 2003 American Control Conference, 2003., 4-6 June 2003, Denver, CO, USA, 2003: 4989-4996.

刘春强 , 骆光照 , 涂文聪 , 等 . 基于自抗扰控制的双环伺服系统 . 中国电机工程学报 , 2017 . 37 ( 23 ): 7032 - 7039, 7095 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201723029 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201723029 .

CH Q LIU , G ZH LUO , W C TU , 等 . Servo systems with double closed-loops based on active disturbance rejection controllers . Proceedings of the CSEE , 2017 . 37 ( 23 ): 7032 - 7039, 7095 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201723029 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201723029 .

C DU , Z G YIN , Y P ZHANG , 等 . Research on active disturbance rejection control with parameter autotune mechanism for induction motors based on adaptive particle swarm optimization algorithm with dynamic inertia weight . IEEE Transactions on Power Electronics , 2019 . 34 ( 3 ): 2841 - 2855 .

F WANG , R J WANG , E H LIU , 等 . Stabilization control mothed for two-axis inertially stabilized platform based on active disturbance rejection control with noise reduction disturbance observer . IEEE Access , 2019 . 7 99521 - 99529 .

刘玉燕 , 刘吉臻 , 周世梁 . 基于降阶状态观测器的压水堆功率自抗扰控制 . 中国电机工程学报 , 2017 . 37 ( 22 ): 6666 - 6674, 6779 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201722023 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201722023 .

Y Y LIU , J ZH LIU , SH L ZHOU . Active disturbance rejection control of pressurized water reactor power based on reduced-order extended state observer . Proceedings of the CSEE , 2017 . 37 ( 22 ): 6666 - 6674, 6779 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201722023 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201722023 .

H X LIU , S H LI . Speed control for PMSM servo system using predictive functional control and extended state observer . IEEE Transactions on Industrial Electronics , 2012 . 59 ( 2 ): 1171 - 1183 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=9df79e371999e361fd4e4b92aac49754 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=9df79e371999e361fd4e4b92aac49754 .

宋俊材 , 董菲 , 赵吉文 , 等 . 基于重心邻域算法的无铁心永磁同步直线电机优化设计研究 . 中国电机工程学报 , 2017 . 37 ( 12 ): 3594 - 3601, 3688 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201712026 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201712026 .

J C SONG , F DONG , J W ZHAO , 等 . Design optimization research of air-core permanent magnet permanent magnet synchronous linear motor based on gravity neighborhood center algorithm . Proceedings of the CSEE , 2017 . 37 ( 12 ): 3594 - 3601, 3688 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201712026 http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=zgdjgcxb201712026 .

Views

401

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176855 Email：gxjmgc@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰