静电驱动的亚微米悬臂梁谐振器非线性特性

岳东旭; 于虹; 袁卫民

doi:10.3788/OPE.20111904.0783

您当前的位置：

首页 >

文章列表页 >

静电驱动的亚微米悬臂梁谐振器非线性特性

微纳技术与精密机械 | 更新时间：2020-08-12

- 静电驱动的亚微米悬臂梁谐振器非线性特性
- Nonlinear characteristics of sub-micron cantilever beam resonators actuated by statical electricity
- 光学精密工程 2011年19卷第4期页码：783-788
- 作者机构：
  
  东南大学电子科学与工程学院 MEMS教育部重点实验室,江苏南京 210096
- 作者简介：
- 基金信息：
  
  国家973重点基础研究发展计划资助项目(No.2006CB300404)();国家863高技术研究发展计划资助项目(No.2007AA04Z301)()
- DOI：10.3788/OPE.20111904.0783
  中图分类号： TP212.1
- 收稿日期：2010-03-15，
  
  修回日期：2010-05-28，
  
  网络出版日期：2011-04-26，
  
  纸质出版日期：2011-04-26
- 稿件说明：
移动端阅览
岳东旭, 于虹, 袁卫民. 静电驱动的亚微米悬臂梁谐振器非线性特性[J]. 光学精密工程, 2011,19(4): 783-788

YUE Dong-xu, YU Hong, YUAN Wei-min. Nonlinear characteristics of sub-micron cantilever beam resonators actuated by statical electricity[J]. Editorial Office of Optics and Precision Engineering, 2011,19(4): 783-788
岳东旭, 于虹, 袁卫民. 静电驱动的亚微米悬臂梁谐振器非线性特性[J]. 光学精密工程, 2011,19(4): 783-788 DOI： 10.3788/OPE.20111904.0783.

YUE Dong-xu, YU Hong, YUAN Wei-min. Nonlinear characteristics of sub-micron cantilever beam resonators actuated by statical electricity[J]. Editorial Office of Optics and Precision Engineering, 2011,19(4): 783-788 DOI： 10.3788/OPE.20111904.0783.

摘要

理论分析了亚微米尺寸的悬臂梁结构的非线性力学模型

研究了非线性产生的物理机制。采用外部静电激励机制

使悬臂梁谐振器产生谐振

借助Polytec激光多普勒测振系统检测了悬臂梁的频率响应曲线。测试结果表明

悬臂梁具有显著的非线性效应(即"弹簧变软"效应)。实验证实了这种非线性效应几乎和交流电压无关

却随着直流电压的增大而显著增大

最大峰值偏移达到 0.5 MHz。提取出3组一阶机械弹性系数分别为79.62

31.75和14.92 N/m

实验结果符合理论规律。对实验中的偏差做了进一步的分析和讨论

利用软件ANSYS对过腐蚀对结构刚度和频率响应的影响做了相应的模拟

结果和实验测量数据相吻合。

Abstract

A nonlinear mechanical model for sub-micron cantilevers was analyzed in detail and its physical mechanism was researched to provide a theoretical basis for experiments.The electrostatical force was used to achieve the resonance state cantilever beams and a Polytec laser Doppler vibration measurement system was taken to observe the frequency response curve. Experimental results show that the beams have significant nonlinear effects (the spring softening effect) and the nonlinearity is relatively independent on the AC voltage

but it is markedly enhanced with increasing the DC voltage. The obtained maximum peak shift is 0.5 MHz and extracted first-order mechanical elasticity coefficients are 79.62

31.75

and 14.92 N/m

respectively. Furthermore

the deviation of the experiment was also disccussed and analyzed.The effects of overetching by wet chemical etching on the stiffness and frequency response were stimulated by ANSYS software.In conclusion

the corresponding simulation results are well coincident with the experimental data.

关键词

Keywords

references

陈国炜,朱荣. 基于氧化锌纳米线的硅谐振式加速度计[J]. 光学精密工程,2009,17(6):1279-1285. CHEN G W, ZHU R. Silicon micromachined accelerometer base on ZnO nanowire [J]. Opt. Precision Eng., 2009,17(6):1279-1285. (in Chinese)[2] 莫绍孟,陈剑鸣,吴光敏,等. 独特谐振模式下薄膜体声波谐振器的设计[J]. 光学精密工程,2009,17(6):1251-1256. MO SH W, CHEN J M, WU G M, et al.. Design of thin film bulk acoustic resonator under unique mode[J]. Opt. Precision Eng., 2009,17(6):1251-1256. (in Chinese)[3] 李应良,潘武. 射频系统中的MEMS谐振器和滤波器[J]. 光学精密工程,2004,12(1):47-54. LI Y L , PAN W . MEMS resonators and filters in RF systems [J]. Opt. Precision Eng., 2004, 12(1):47-54. (in Chinese)[4] RHOAD J F, SHAW S W, TURNER K L, et al..Tunable microelectromechanical filters that exploit parametric resonance[J]. Vibr. Acoust,2005,127(5):423-430.[5] ARLETT J L,MALONEY J R, GUDLWSKI B,et al.. Self-sensing micro-and nanocantilevers with attonewton-scale force resolution[J].Nano Letters, 2006,6(5):1000-1006.[6] ERBE A,KROMMER H,KRAUS.Mechnical mixing in nonlinear nanomechanical resonators[J].Appl Phys Lett.,2000,77(19):3102-3104.[7] AGARWAL M, PARK K K,CANDLER R N.Nonlinear characterization of electrostatic MEMS reaonator[J].IEEE Frequency ControSymposuim,2006:209-212.[8] PALANIPAN M,KHINE L.Nonlinear behavior of SOI free-free micromechanical beam resonator[J]. Sensors and Actuators,2008,142:203-210.[9] SHAO L C,PALANIPAN M,TAN W W.The nonlinearity cancellation phenomenon in mechanical resonators [J].Journal of Micromechanical and Microengineering , 2008,18:065014(9pp).[10] LANDAU L D, LIFSHITZ E M. Mechanics[M].3rd ed. Oxford:Butterworth-Heinemann,1999.[11] CHOWDHURY S,AHMADI M, MILER W C. A closed form model for the pull-involtage of electrostatically actuated cantilever beams[J].Journal of Micromechanical and Microengineering, 2005,15:756-763. [12] ZHAO J H, BRIDGE G E, THOMSON D J. Direct evidence of "spring softening"nonlinearity in micromachined mechanical resonator using optical beam deflection technique American Vacuum Society[J].J. Vac.Sci.Technol.,2006,24(3):732-736.

浏览量

452

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

叠堆式超磁致伸缩致动器的模型预测滑模控制

2 m级望远镜跟踪架控制系统动态性能分析

2 m望远镜主轴交流伺服控制系统设计

微机电陀螺耦合刚度的辨识

电动舵机伺服系统非线性辨识及补偿