调幅式电容位移传感器的峰值检波电路设计

黄向东; 刘立丰; 谭久彬; 马标

doi:10.3788/OPE.20122011.2444

您当前的位置：

首页 >

文章列表页 >

调幅式电容位移传感器的峰值检波电路设计

微纳技术与精密机械 | 更新时间：2020-08-12

- 调幅式电容位移传感器的峰值检波电路设计
- Design of peak detector circuit for AM capacitive displacement sensor
- 光学精密工程 2012年20卷第11期页码：2444-2449
- 作者机构：
  
  哈尔滨工业大学超精密光电仪器工程研究所,黑龙江哈尔滨,150001
- 作者简介：
- 基金信息：
  
  国家自然科学基金(面上)资助项目(No.51075096)();黑龙江省留学归国人员基金资助项目 (No.LC201038/40000045-6-10400-01)()
- DOI：10.3788/OPE.20122011.2444
  中图分类号： TP212.12
- 收稿日期：2012-06-15，
  
  修回日期：2012-09-05，
  
  纸质出版日期：2012-11-10
- 稿件说明：
移动端阅览
黄向东, 刘立丰, 谭久彬, 马标. 调幅式电容位移传感器的峰值检波电路设计[J]. 光学精密工程, 2012,20(11): 2444-2449

HUANG Xiang-dong, LIU Li-feng, TAN Jiu-bin, Ma Biao. Design of peak detector circuit for AM capacitive displacement sensor[J]. Editorial Office of Optics and Precision Engineering, 2012,20(11): 2444-2449
黄向东, 刘立丰, 谭久彬, 马标. 调幅式电容位移传感器的峰值检波电路设计[J]. 光学精密工程, 2012,20(11): 2444-2449 DOI： 10.3788/OPE.20122011.2444.

HUANG Xiang-dong, LIU Li-feng, TAN Jiu-bin, Ma Biao. Design of peak detector circuit for AM capacitive displacement sensor[J]. Editorial Office of Optics and Precision Engineering, 2012,20(11): 2444-2449 DOI： 10.3788/OPE.20122011.2444.

摘要

针对调幅式电容位移传感器解调过程中由系统不确定相移导致的信号解调不准确问题

提出了一种基于改进的峰值保持电路的调幅式电容位移传感测量方法。首先

分析了调幅式电容位移传感器及其检测电路的工作原理

在研究调幅信号附加相移产生机理的基础上

提出了延迟反馈式峰值保持电路

用以去除附加相移对峰值解调的影响。然后

设计并制作了调幅式电容位移传感器

并对其各个性能指标进行了测试。最后

对实验结果和误差进行了分析。实验显示

提出的峰值保持电路的输出线性度优于0.05%

制作的传感器在0~25 m内数据测量稳定性优于10 nm/30 min

传感器测量偏差最大值为36 nm。结果表明

采用延迟反馈型峰值保持电路有效地解决了系统不确定相移带来的峰值检波不准确的问题

所制作的电容传感器满足了高精度测量的要求。

Abstract

To solve the problem of inaccurate peak demodulation resulted from the system uncertain phase shift in Amplitude Modulation (AM) for a capacitive displacement sensor

an AM capacitive displacement sensor based on an improved delayed feedback peak detector circuit was proposed and its applied functional blocks and circuits were investigated. Firstly

the measurement principles of the AM capacitive displacement sensor and its detection circuit were analyzed. Based on generation principle of phase shift with the AM signal

an improved delayed feedback peak detector was presented against the problem of inaccurate peak demodulation. Then

the AM capacitive displacement sensor was prototyped using printed circuit boards and its performance indicators were tested as well. Finally

experimental results and errors were discussed. It indicates that the linearity of the delayed feedback peak detector circuit is better than 0.05%

the data shift of prototyped sensor is less than 10 nm/30 min

and the maximum deviation of sensor is 36 nm within the measuring range of 0~25 m. It concludes that the delayed feedback peak detector circuit can effectively solve the problem of inaccurate peak detector resulted from the system uncertain phase shift

and the proposed AM capacitive sensor can satisfy the requirements of high precision measurement.

关键词

Keywords

references

李达成,王佳. 纳米科学测量与传感技术[J]. 仪器仪表学报.1995,16(1):76-78. LI D CH, WANG J. The measurement and sensor in nanometer scale science [J]. Chinese Journal of Scientific Instrument, 1995, 16(1): 76-78. (in Chinese)[2] HEERENS W C, Application of capacitive techniques in sensor design [J]. Phys. E:Sci.Instrum, 1986,19(11):897-906.[3] NURUL A, ALAM A H M Z, KHAN S. Design of capacitive measuring systems for high frequency band sensor transducer. ICCCE, Kuala Lumpur, Malaysia, 2010:11-13.[4] 马洪宇,黄庆安,秦明. 谐振式MEMS温度传感器设计 [J]. 光学精密工程.2010,18(9):2023-2027. MA H Y, HUANG Q A, QIN M. Design of resonant MEMS temperature sensor [J]. Opt. Precision Eng., 2010,18(9):2023-2027.(in Chinese)[5] 赵振刚,刘晓为,王鑫,等. 基于555多谐振荡器检测的碳纳米管湿敏传感器 [J]. 光学精密工程. 2011,19(1):119-122. ZHAO ZH G, LIU X W, WANG X, et al.. Carbon nanotube sensors based on 555 multivibrators [J]. Opt. Precision Eng., 2011,19(1):119-122. (in Chinese)[6] MANET G, LUCAS V D H, XIUJUN L. A contactless capacitive angular-position sensor [J]. Proceedings of IEEE Sensors,2002,1(2):880-884.[7] 赵玉刚,邱东. 传感器基础 [M]. 北京:中国林业出版社;北京大学出版社,2006,8:1-2. ZHAO Y G, QIU D. Basis of Sensor [M]. Beijing: China Forestry Press: Peking University Press, 2006, 8:1-2. (in Chinese)[8] 赵维谦,谭久彬,刘冰峰,等. 改善调幅式传感器测量电路精度的措施[J]. 仪器仪表学报. 2001,22(3):247-230. ZHAO W Q, TAN J B, LIU B F, et al.. Measurements of improving the precision of amplitude modulation measurement circuit of inductance sensor [J]. Chinese Journal of Scientific Instrument,2001, 22(3): 247-230. (in Chinese)[9] ANDREW L H. Displacement transducers based on reactive sensors in transformer ratio bridge circuits[J]. Instrument Science and Technology, 1982, 15(6): 597-606.[10] HUANG S M, STOTT A L, GREEN R G, et al.. Electronic transducers for industrial measurement of low value capacitances [J]. Phys. E: Sci. Instrum, 1988, 21(3):242-250.

浏览量

539

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

滑动式光纤布拉格光栅位移传感器

基于光敏阵列直接调制的单栅式时栅位移传感器

磁致伸缩位移传感器检测信号分析

电容传感器线性度标定平台

电容式位移传感器的线性度标定与不确定度评定