氮气反应溅射制备软X射线Co/Ti多层膜

朱京涛; 岳帅鹏; 涂昱淳; 张一志

doi:10.3788/OPE.20152301.0010

您当前的位置：

首页 >

文章列表页 >

氮气反应溅射制备软X射线Co/Ti多层膜

现代应用光学 | 更新时间：2020-08-13

- 氮气反应溅射制备软X射线Co/Ti多层膜
- Preparation of Co/Ti multilayer in soft X-ray region by nitrogen reactive sputtering
- 光学精密工程 2015年23卷第1期页码：10-14
- 作者机构：
  
  同济大学物理科学与工程系精密光学工程技术研究所上海,200092
- 作者简介：
- 基金信息：
  
  国家自然科学基金资助项目(No.11375131,No.11305104)();国家973重点基础研究发展计划资助项目(No.2011CB922203)()
- DOI：10.3788/OPE.20152301.0010
  中图分类号： O484.1
- 收稿日期：2014-02-28，
  
  修回日期：2014-04-24，
  
  纸质出版日期：2015-01-25
- 稿件说明：
移动端阅览
朱京涛, 岳帅鹏, 涂昱淳等. 氮气反应溅射制备软X射线Co/Ti多层膜[J]. 光学精密工程, 2015,23(1): 10-14

ZHU Jing-tao, YUE Shuai-peng, TU Yu-chun etc. Preparation of Co/Ti multilayer in soft X-ray region by nitrogen reactive sputtering[J]. Editorial Office of Optics and Precision Engineering, 2015,23(1): 10-14
朱京涛, 岳帅鹏, 涂昱淳等. 氮气反应溅射制备软X射线Co/Ti多层膜[J]. 光学精密工程, 2015,23(1): 10-14 DOI： 10.3788/OPE.20152301.0010.

ZHU Jing-tao, YUE Shuai-peng, TU Yu-chun etc. Preparation of Co/Ti multilayer in soft X-ray region by nitrogen reactive sputtering[J]. Editorial Office of Optics and Precision Engineering, 2015,23(1): 10-14 DOI： 10.3788/OPE.20152301.0010.

摘要

针对"水窗"波段(280~540 eV)对多层膜反射镜的应用需求

在Ti的L吸收边(452.5 eV)附近

优化设计了Co/Ti多层膜的膜系结构.计算了不同界面粗糙度条件下的反射率

结果显示

界面粗糙度对多层膜反射率有较大影响.采用直流磁控溅射方法在超光滑硅基片上制备了Co/Ti多层膜

通过将氮气引入原有的溅射气体氩气中作为反应气体

明显减小了制备的多层膜的界面粗糙度.利用X射线掠入射反射实验和透射电子显微镜测试了多层膜结构

并在北京同步辐射装置(BSRF)3W1B实验站测量了不同氮气浓度下多层膜的反射率.结果显示

氮气含量为5%的溅射气体制备的多层膜样品反射率最高

即将纯氩气溅射制备得到的反射率9.5%提高到了12.0%.得到的结果表明

将氮气加入反应溅射气体可以有效改善Co/Ti多层膜的性能.

Abstract

The film system structures of Co/Ti multilayer film were designed optimally at the L-absorption edge of Ti(452.5 eV) to meet the requirements of a multilayer mirror at the ‘water window’ energy region between 280 eV and 540 eV. The reflectivity of the multilayer film was calculated at different interface roughness conditions and it shows that the interface roughness has greater effect on the reflectivity of the multilayer film. Co/Ti multilayer films were deposited on a Si substrate by DC magnetron sputtering method and the quality of these films was improved by adding nitrogen gas into original argon gas in magnetron sputtering. Finally

the multilayer film structure was measured by a Grazing Incident X-ray Reflection (GIXRR) method and a Transmission Electron Microscope(TEM)

and the reflectivities in different nitrogen concentrations were measured by Soft X-ray Reflectivity(SXR) at Beijing Synchrotron Radiation Facility(BSRF). The results show that the reflectivity of the Co/Ti multilayer with nitrogen gas fraction of 5% is the highest among the samples

by which the reflectivity has been improved from 9.5% to 12.0%. The results demonstrate that the reaction sputtering with nitrogen gas improves the quality of Co/Ti multilayer films effectively.

关键词

Keywords

references

马斌,王占山,王洪昌,等. 水窗波段反射式偏振光学元件的设计和制作[J]. 光学学报,2005,25(11):1581-1584. MA B, WANG ZH SH, WANG H CH, et al.. Design and fabrication of the polarizing elements of reflection multilayer film in water window wave band [J]. Acta Optica Sinica, 2005,25(11):1581-1584.(in Chinese)

MUAMER Z, JONGMIN K, MICHELE W, et al.. Nongrazing high reflective narrow band multilayer X-ray coatings [J].SPIE,1993,2011:322-333.

ZHONG J Y, WANG C, ZHANG J, et al.. Driver-puls econfiguration of the nickel like Ta X-ray laser at 4.48 nm [J].Phys. Rev.A,2004,70:053803:1-6.

MAXON S, ESTABROOK K G, PRASAD M K, et al.. High gain X ray lasers at the water window [J]. Phys. Rev.Lett., 1993,70(15): 2285-2288.

张立超. 极紫外多层膜技术研究进展[J]. 中国光学与应用光学,2010,3(6): 554-565. ZHANG L CH. Progress in EUV multilayer coating technologies[J]. Chinese Journal of Optics and Applied Optics, 2010,3(6): 554-565.(in Chinese)

SELLA C, MAAZA M, KAABOUCHI M, et al.. Annealing effects on the structure and magnetic properties of NiyTi multilayers [J]. Magn. Magn. Mater.,1993,121:201-204.

MAAZA M, FAMOUX B, SAMUEL F, et al.. Reduction of the interfacial diffusion in Ni-Ti neutron-optics multilayers by carburation of the Ni-Ti interfaces [J]. Appl. Crystallogr, 1993,26:574-582.

MONTCALM C, PATRICK A, SLAUGHTER K J M, et al.. Survey of Ti-, B-, and Y-based soft X-ray-extreme ultraviolet multilayer mirrors for the 2 nm to 12 nm wavelength region[J]. Applied Optics, 1996,35(25):5134-5147.

SASA BAJT, JENNIFER B, TROY W, et al.. Improved reflectance and stability of Mo-Si multilayers [J]. Opt. Eng., 2002,41(8):1797-1804.

申振峰. 特定折射率材料及光学薄膜制备[J]. 中国光学, 2013,6(6): 900-905. SHEN ZH F. Preparation of specific refractive index material and optical thin films[J]. Chinese Optics, 2013,6(6): 900-905.(in Chinese)

GHAFOOR N, ERIKSSON F, GULLIKSON E, et al.. Incorporation of nitrogen in Cr/Sc multilayers giving improved soft x-ray reflectivity [J]. Applied Physics Letters, 2008,92:091913.

WINDT D L, BELLOTTI J A. Performance,structure,and stability of SiC/Al multilayer films for extreme ultraviolet applications[J]. Applied Optics, 2009,48(26):4932-4941.

WINDT D L.IMD: Software for modeling the optical properties of multilayer films[J]. Comput.Phys.,1998,12:360-370.

王风丽, 王占山, 张众,等. W/B4C、W/C、W/Si多层膜的研究[J]. 光学精密工程,2005,13(1):28-33. WANG F L, WANG ZH SH, ZHANG ZH, et al.. W/B4C、W/C、W/Si multilayers[J]. Opt. Precision Eng.,2005,13(1):28-33.(in Chinese)

浏览量

355

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

高性能大尺寸X射线多层膜反射元件研制进展

用于中子小角散射的中子反射镜聚焦性能评价

高Sc含量ScAlN薄膜的制备与表征

基于离子束溅射Ta2O5薄膜的紫外吸收膜技术

基于离子束溅射Ta₂O₅薄膜的紫外吸收膜技术