空间高精度扫描伺服系统的驱动控制

翟少雄; 王长胜; 谭立; 高波

doi:10.3788/OPE.20162405.1104

您当前的位置：

首页 >

文章列表页 >

空间高精度扫描伺服系统的驱动控制

微纳技术与精密机械 | 更新时间：2020-08-13

- 空间高精度扫描伺服系统的驱动控制
- Driving and controlling of high accuracy scanning servo-system in space
- 光学精密工程 2016年24卷第5期页码：1104-1111
- 作者机构：
  
  兰州空间技术物理研究所真空技术与物理重点实验室,甘肃兰州,730000
- 作者简介：
- 基金信息：
  
  国防科技工业民用专项资金资助项目(No.C4220060328)()
- DOI：10.3788/OPE.20162405.1104
  中图分类号： V475;TP273
- 收稿日期：2015-12-11，
  
  修回日期：2016-01-20，
  
  纸质出版日期：2016-05-25
- 稿件说明：
移动端阅览
翟少雄, 王长胜, 谭立等. 空间高精度扫描伺服系统的驱动控制[J]. 光学精密工程, 2016,24(5): 1104-1111

ZHAI Shao-xiong, WANG Chang-sheng, TAN Li etc. Driving and controlling of high accuracy scanning servo-system in space[J]. Editorial Office of Optics and Precision Engineering, 2016,24(5): 1104-1111
翟少雄, 王长胜, 谭立等. 空间高精度扫描伺服系统的驱动控制[J]. 光学精密工程, 2016,24(5): 1104-1111 DOI： 10.3788/OPE.20162405.1104.

ZHAI Shao-xiong, WANG Chang-sheng, TAN Li etc. Driving and controlling of high accuracy scanning servo-system in space[J]. Editorial Office of Optics and Precision Engineering, 2016,24(5): 1104-1111 DOI： 10.3788/OPE.20162405.1104.

摘要

研究了空间飞行器扫描伺服系统的高精度驱动控制技术。针对有效载荷对地面目标进行扫描时多要求其伺服系统提供高精度的低速性能

本文提出采用交流永磁同步电机直接驱动伺服系统

省去中间的减速器传动环节来提高伺服系统的驱动控制精度。伺服驱动控制系统用现场可编程门阵列(FPGA)作为高速信号处理芯片

提高信号的处理速度和控制精度;用高精度的绝对式光电编码器检测转动位置

提高位置检测和速度的精度;主电路采用功率线性放大技术

得到光滑

力矩脉动小的驱动波形。系统实验表明

由于该方法采用模拟正弦信号驱动

在低速时避免了脉宽调制(PWM)驱动信号开关和死区造成的速度波动

实现了高精度的速度控制

速度波动范围在1%以内;得到的电压、电流测试曲线光滑

无高次谐波干扰。该扫描伺服系统满足动态和静态要求

为实现空间低速高精度扫描提供了一种新的方法。

Abstract

A high accurate servo control technology was explored for the scanning servo-system of a spacecraft. When payloads such as space communication

observation and reconnaissance scan the targets on the ground

the servo system of payloads usually is required to provide high accuracy and low speed performance. So

this paper proposes a control scheme by using a Permanent Magnet Synchronous Motor (PMSM) as the servo driving system. It avoids the middle processing of a reducer and improves the control accuracy of servo system. A Field Programming Gate Array(FPGA) was used in the servo driving control system as the signal processing chip to improve the process speeds and control accuracy

and a higher precise absolute photoelectric encoder was taken to detect the rotation position to increase the detection accuracy of the speed and position. Furthermore

a power linear amplification was used in the main circuit to obtain smoother and smaller fluctuation wave forms. As the control scheme uses simulation sinusoidal signal driving and it avoids speed fluctuation come from switching and dead zones of the pulse width modulation(PWM) signals in low speeds

the experiments indicate that the control scheme realizes the speed control with high accuracy. The speed is smooth

and the speed fluctuation is within 1% when the operating is in an even speed. Moreover

the testing curves of the voltage and current are smoother without harmonic disturbance. The scan servo system meets the requirements of dynamic and static experiments

and provides a new solution for low speed and high precision scanning servo systems.

关键词

Keywords

references

王淦泉,陈桂林. 地球同步轨道二维扫描红外成像技术[J]. 红外与激光工程,2014,43(2):429-433. WANG G Q, CHEN G L.Two dimensional scanning infrared imaging technology on geosynchronous orbit[J]. Infrared and Laser Engineering,.2014,43(2):429-433. (in Chinese)

边志强,蔡陈生,吕旺,等. 遥感卫星高精度高稳定度控制技术[J]. 上海航天, 2014,31(3):24-38. BIAN ZH Q,CAI CH SH,LV W,et al... High accuracy and high stability control technology of remote sensing satellite[J].Aerospace Shanghai, 2014,31(3):24-38. (in Chinese)

高钟毓. 机电控制工程[M]. 北京:清华大学出版社,2002. GAO Z Y.Mechanical and Electrical Control Engineering[M].Beijing:Tinghua University Press,2002. (in Chinese)

胡崇岳. 现代交流调速技术[M]. 北京:机械工业出版社, 2001. HU CH Y.Modern AC Speed Regulation Technology[M].Beijing:Machinery industry Press,2001. (in Chinese)

Cyclone FPGA Family Data Sheet:Altera,2013:163-165.

马志源. 电力拖动控制系统[M]. 北京:科学出版社,2004. MAI Z Y.Electric Driver Control System[M].Beijing:Science Press,2004. (in Chinese)

李华德. 交流调速控制系统[M]. 北京:电子工业出版社,2009. LI H D.AC Speed Control System[M].Beijing:Electronics Industry Press,2009. (in Chinese)

李华德. 电力拖动控制系统(运动控制系统)[M]. 北京:电子工业出版社,2006. LI H D.Electric Driver Control System[M]. Beijing:Electronics Industry Press,2006. (in Chinese)

王中. 基于DSP和FPGA的高精度交流伺服系统研究[D]. 武汉:华中科技大学,2006. WANG ZH.Research on High Precision AC Servo System based on DSP and FPGA[D]. Wuhan:Huazhong University of Science & Technology, 2006. (in Chinese)

BRIAN J.Workman and Eric Schwartzbaum,The SeaWinds Scatterometer Antenna Subsystem on the Quick Scat Spacecraft[C].Proceedings of the 34th Aerospace Mechanisms Symposium,Goddard Space Flight Center,2013(10-12):275-286.

侯姗姗,雷莉萍,关贤华. 温室气体观测卫星GOSAT及产品[J]. 遥感技术与应用,2013,28(2):269-275. HOU S S,LEI L P,GUAN X H. A general introduction to Greenhouse Gases Observing Satellite(GOSAT) and its products[J]. Remote Sensing Technology and Application, 2013,28(2):269-275. (in Chinese)

MANFRED S, LI J, CHRISTIAN H.Scanning mechanism of the FY-3 microwave humidity sounder[J]. Proceedings of the 40th Aerospace Mechanisms Symposium, NASA Kennedy Space Center, 2010(12-14):87-98.

翟少雄,黄声华,王长胜,等. 适于特殊场合的步进电机驱动电源技术研究[J]. 微电机,2008,41(12):33-35. ZHAI SH X,HUANG SH H,WANG CH SH,et al..Study of step motor driver power technology applied in special enviroment[J].Micromotors,2008,41(12):33-35. (in Chinese)

RAHMAN M A. Analysis of brushless permanent magnet synchronous motor[J].IEEE Transon Electronics,2013,43(2):256-267.

CHRISTION D, VINCENT L, JEAN B, et al..Closed-loop control of virtual FPGA-coded permanent magnet synchronous motor drives using a rapidly prototyped controller[J].13th International Power Electronics and Motion Control Conference, 2008:1077-1083.

LOW K S, KECK M T.Optimum predictive and feedforward control of a precision linear stage using genetic algorithm[J].The 35th Annual Conference of the IEEE,2009(3):1289-1294.

CHANWOO M, SUNGHO L, CHUNG,et al..Precise position control of a linear stage integrated with an inchworm type actuat or,SICE[J].Annual Conference,2004(1):572-576.

JUNG D H,HA I J. An efficient method for identifying the initial position of a PMSM with an incremental encoder[J].IEEE Trans on Industrial Electronics,2008,45(4):682-685.

HENRIKSEN S J, BETZ R E, COOK B J. Digital hardware implementation of a current controller for IM variable-speed drives[J]. IEEE Trans on IndustrialApplication, 2014,35(5):1021-1029.

BRAD S."Total" Current Control of Brushless DC Motors with Sinewave Drive,2014:216-220.

SERGEY E L, TREVOR C S.Tracking control of direct-drive servos[J]. 50th IEEE Conference on Decision and Control and European Control Conference(CDC-ECC) Orlando,FL,USA,December,2011(12-15):1602-1607.

KONATE C, KOSONEN A, AHOLA J, et al.. Induction motor speed control using power line communication[J].IEEE,France,2013.261-266.

周腊吾,石书琪. 一种新型的PMSM直接转矩控制[J]. 湖南大学学报(自然科学版),2011,138(8):40-44. ZHOU L W,SHI SH Q. A new direct torque control of PMSM[J].Journal of Hunan University(Natural Sciences), 2011,138(8):40-44. (in Chinese)

杨维帆,徐抒岩,曹小涛,等. 空间光学遥感器扫描控制系统设计[J]. 光学精密工程, 2014,22(2):397-405. YANG W F,XU SH Y,CAO X T, et al.. Design of scanning control system for space optical remote sensor[J].Opt. Precision Eng., 2014,22(2):397-405. (in Chinese)

浏览量

639

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

空间飞行器弹道/轨道一体化快速设计

基于速度信号的扰动观测器及在光电稳定平台的应用